Technical Service Bulletins

2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-07-17: Essential Service Tool update #4 (U.S. Retailers Only) (08-00-89-025)
2008-06-23: Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-03-31: Radio Unlock Code Procedure - keywords accessory activation body code disabled delco information inoperative number panasonic phone program security support theft theftloc (PIC4837)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-25: Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-28: Battery Electrical Drain / Parasitic Load Test - keywords dead draw drop resistor voltage (PIC4790)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2007-12-13: Essential Service Tool Update #8 (U.S. Retailers Only) (07-00-89-061)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-29: GWM Warranty Parts Center Return Program (05-00-89-042C)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-10-24: Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-07-19: Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
2007-06-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for June, 2007 (06-00-89-041G)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-18: Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-01-23: Info - Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2006-11-27: Info - New Bulletin Categories (05-00-89-005A)
2006-11-17: Info - Essential Service Tool Update Number 8 (U.S. Retailers Only) (06-00-89-049)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-09-15: Information Regarding Updated PC Grade Specifications and Techline Support (U.S. Only) (06-00-89-045)
2006-09-14: Information for Diagnosing and Servicing Customer Concerns of Vehicle Creeping Forward in Neutral, binding in Reverse and/or Clicking or Whining in All Forward Gears After Transaxle Service (06-07-30-024)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-06-05: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for May, 2006 (06-00-89-028)
2006-05-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-31: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for March, 2006 (06-00-89-017)
2006-03-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for February, 2006 (06-00-89-012)
2006-02-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for December, 2005 and January, 2006 (06-00-89-007)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-27: Info - Essetnial Service Tool Update No. 1 (U.S. Retailers Only) (06-00-89-005)
2005-12-21: Info - Essential Service Tool Update No. 7 (U.S. Retailers Only) (05-00-89-087)
2005-12-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for November, 2005 (05-00-89-085)
2005-11-23: Info - Essential Service Tool Update Number 6 (U.S. Retailers Only) (05-00-89-081)
2005-11-18: Warranty Admin. - Warranty Parts Center/Saturn Parts Return Program Concerns (05-00-89-080)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-11-04: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for October, 2005 (05-00-89-077)
2005-10-26: Info - Transition of Saturn Technical Training to GM Service Technical College (STC) Training Program (U.S. Only) (05-00-89-073)
2005-10-03: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for September, 2005 (05-00-89-064)
2005-09-23: Info - Essential Service Tool Update Number 5 (U.S. Retailers Only) (05-00-89-063)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-09-09: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in July and August, 2005 (05-00-89-061)
2005-08-26: Info - Essential Service Tool Update #4 (U.S. Retailers Only) (05-00-89-058)
2005-08-22: Warranty Admin. - Restriction on Battery Warranty Claims (05-06-03-006)
2005-08-22: Ignition Key Will Not Fit in Cylinder Causing No Crank, No Start - keywords fit key lock start steering (PIC3652)
2005-08-11: Info - Pinstripe/Vinyl Graphic Installation Tips and Techniques (04-08-51-004A)
2005-07-21: Enhancement to Saturn Goodwill Rental Car Program (U.S. Only) (05-00-89-044)
2005-07-01: Info - Essential Service Tool Update Number 3 (U.S. Retailers Only) (05-00-89-040)
2005-07-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in June, 2005 (05-00-89-039)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-23: Warranty Admin. - GM New Vehicle Tire Warranty Program (U.S. Only) (05-03-10-009)
2005-06-02: Saturn Field Product Reminder-Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in May, 2005 (05-00-89-033)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in April, 2005 (05-00-89-028)
2005-04-27: Info - Labor Time Guide Requests for Review (U.S. Retailers Only) (05-00-89-026)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-15: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in February and March, 2005 (05-00-89-016)
2005-02-23: Info - Extended Warranty Available for Saturn Tech 2 Scan Tools (05-00-89-010)
2005-02-11: Quick Tips for Warranty Administration (05-00-89-007)
2005-02-02: Power Steering System Noise and/or Leak Diagnosis (02-02-32-009A)
2005-01-31: Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Bulletins Released in December 2004 and January 2005 (05-00-89-004)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2005-01-04: ( DRL ) Logic Location - Assists with Proper Part Number Replacement - kw lamp light inoperative speedometer instrument panel cluster IPC IP part head (PIC3318)
2004-12-21: Delay and/or Harsh into Drive, or Harsh into Reverse or 2nd / 3rd / 4th After Trans Repair - kw bump clunk hesitation upshift shift MP6 MP7 transmission transaxle automatic (PIP3175A)
2004-11-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in November 2004 (04-00-89-058)
2004-10-26: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in October, 2004 (04-00-89-048)
2004-10-22: Hesitation or Stumble During Tip-In Launch After Spark Plug Wires Were Reinstalled or Replaced - kw 1.9 L24 LL0 SOHC DOHC accelerate throttle (PIP3199)
2004-10-20: Info - New Measuring Wheel Alignment Procedure for Labor Operation Numbers E2020 and E2000 (04-03-07-003)
2004-10-07: Cruise Control Is Inoperative or Will Not Set / Engage after the Manual Transaxle Has Been Replaced - kw MP2 MP3 transmission module (PIP3178)
2004-10-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in September 2004 (04-00-89-044)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-08-30: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in August, 2004 (04-00-89-037)
2004-08-26: Replacement Sunroof Module Motor Harness Connection Changes - kw plug terminal (PIC3116)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time issues, Parts Restriction Information and Technical Bulletins Released in June and July 2004 (04-00-89-031)
2004-07-28: 1991-2002 ZB Saturn No Fluid Pressure , No Drive , No Reverse - kw transmission MP7 MP6 inoperative forward automatic A/T gear (PIP3082)
2004-06-15: Saturn Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information and Technical Bulletins Released in May, 2004 (04-00-89-023)
2004-05-27: Info - Remanufactured Transmission and Remanufactured Valve Body Information Requirements (04-07-30-026)
2004-05-06: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in April, 2004 (04-00-89-017)
2004-03-30: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in January, February and March 2004 (04-00-89-012)
2004-01-15: Service Information Regarding Service Applications for Automatic Transaxle Shift Solenoids (00-07-30-024A)
2003-12-01: Service Manual Procedures for New Lock System for Interim 1997 Saturns (96-T-67)
2003-12-01: Inoperative or Intermittent Operation of Many Circuits (99-T-58)
2003-11-25: Ignition Coil Available as a Service Part (P/N16167763, Ignition Coil) (99-T-14)
2003-11-20: Service Information Regarding Anti-Lock Brake (ABS) DTCs 47, 48, and 51 Diagnostic Chart (01-T-60)
2003-09-30: Objectionable Engine Vibration at Idle (95-T-36A)
2003-09-30: Vehicle Vibration Between 77 and 87 KM/H (48 and 54 MPH) (96-T-52A)
2003-09-30: Information on Flat-Towing Saturn S-Series with All Four Wheels on the Ground (00-T-33A)
2003-09-16: Rear Disc Brake Noise and/or Pulsation (Replace with New Rear Disc Brake Pads) (03-05-23-003)
2003-08-29: Info - Clarification of Labor Codes Used for Reprogramming Vehicle Controllers (03-00-89-025)
2003-05-08: Intermittent No Start, Intermittent Stall After Start-Up and/or Loss of Radio Presets (Replace Instrument Panel Junction Block-IPJB and/or Terminal) (03-08-45-001)
2003-04-24: Front and Rear Side Door Window Frame Appliques and/or Windshield Frame Filler Panel Appliques Exhibiting Top Coat Paint Peeling (02-T-71)
2003-04-16: Use of Serial Data Link Diagnostic Communication Tools to Retrieve Mode 6 Data (98-T-75)
2003-04-16: Oil Consumption Concern (94-T-59A)
2003-04-16: Rear Side Door Glass Will Not Go Up or Down, or Will Fall Down Unintentionally (03-T-05)
2003-03-07: Bumps or Iron Dust on Paint Surface (Apply Buffered Oxalic Acid Spray or a Clay Type Non-Acid Based Product Using Manufacturers Recommendations) (99-08-51-006C)
2003-02-25: Power Steering Pump Drive Shaft Seal Leak (98-T-32)
2003-02-25: Design Change to Strut Assemblies (99-T-16)
2003-02-13: Harsh Shifts, No Shifts, and/or No TCC Operation with Transaxle Releated DTCs Set (01-T-09)
2003-02-13: MIL Service Engine Soon Telltale Illuminated with DTC P0711 After Vehicle is Flat-Towed with All Four Wheels on the Ground (01-T-28)
2003-02-13: EVO Diagnosis (96-T-10)
2003-02-13: New Design Upper Engine Mount Assembly (96-T-48)
2003-01-13: Loss of Airflow From A/C Outlets after Extended Periods of Highway Driving (98-T-10A)
2003-01-13: Replacement of Interior Door Panel Inserts (98-T-13)
2003-01-13: Rattle or Buzz Noise During Steady Throttle with Engine Speed Between 1500-2500 RPM (98-T-20)
2003-01-13: Design Changes to Differential Components on Manual and Automatic Transaxles (99-T-12)
2003-01-13: Service Procedures Involving the Liquid Line to TXV Connection of Suction Line to TXV Connection (99-T-42)
2003-01-13: Automatic Transaxle Air Checking Procedures (99-T-56)
2003-01-13: Sizzling or Hissing Type Noise After A/C Use (99-T-65)
2003-01-13: RKE and/or Saturn Security System Inoperative at Temperatures above 36 Degrees Celsius (96-T-62A)
2003-01-13: Changes to Oil Charge for R134a Service A/C compressors and Oil Handling Procedures (98-T-23)
2003-01-10: Clicking, Ticking or Rubbing Noise From the Instrument Cluster Odometers (95-T-27B)
2003-01-10: Diagnostic Information for High/Low Beam Headlamps with DRL (95-T-40)
2003-01-10: RKE Diagnostic Information (95-T-42)
2003-01-10: PCM Diagnostic Information (95-T-44)
2003-01-10: Rear Compartment Lid Key Cylinder Misaligned (95-T-49)
2003-01-10: Sunroof will Not Open or Close, Condition May be Intermittent (95-T-55)
2003-01-10: Decklid Does Not Stay Open in the Full Open Position and/or Too Hard to Open (96-T-02A)
2003-01-10: Squeaks and Rattles Coming From the Upper I/P Area (96-T-11)
2003-01-10: Door Lock do not Operate with Key (96-T-12)
2003-01-10: Tapping Noise Coming From the Dash/Cowl Area (96-T-14)
2003-01-10: Waterleaks into the Rear Luggage Compartment Area (96-T-15A)
2003-01-10: Rear Exterior Door Panel is Not Tight Against the Door Structure (96-T-19C)
2003-01-10: Rattle, Pop, or Clicking Noise from the Front End of the Vehicle Over Rough Road Surfaces (96-T-27A)
2003-01-10: Sunroof Operates Slow, Binds or Becomes Inoperative (96-T-29A)
2003-01-10: Service Manual Information for Automatic Transaxle Delay and/or Harsh Engagement into Reverse Diagnosis (96-T-38A)
2003-01-10: Engine Runs Rough, Surges at idle, Stalls after Start and/or MIL On and PCM/EC DTC 45 or DTC P0172 (96-T-32A)
2003-01-10: Valvebody Cover Gasket Information (95-T-25A)
2003-01-10: Windows Fog Up (01-T-27)
2003-01-10: Electrical Accessories Intermittently Inoperative, MIL On and DTCs Set in PCM Memory, and/or Key Binds in RUN Position (96-T-50A)
2003-01-10: Procedure for the Removal and Installation of the Windshield Defroster Nozzle Duct Assembly (96-T-53)
2003-01-10: Procedure for the Removal and Installation of the Sunroof Switch Assembly (96-T-54)
2003-01-10: Creak in the Rear Window Area (97-T-09B)
2003-01-10: Corrosion on Door White Deposits on Door Primary Weatherstrip (97-T-23A)
2003-01-10: Squeak and/or Rattle Noise from the Rear End of the Vehicle over Rough Road Surfaces (97-T-27)
2003-01-10: Rattle, Buzz and/or Clunk From the Front Door over Rough Road and/or with the Radio On (98-T-03A)
2003-01-09: Installation Procedures for Trap Resistant Trunk Kit (99-T-08)
2003-01-09: Waterleaks at Right and/or Left Front Footwell Area (94-T-32C)
2003-01-08: Bumps or Rust Colored Spots in the Paint Due to Rail or Iron Dust (94-T-09B)
2003-01-08: Whistle Type Windnoise at Highway Speeds, or Groaning Type Noise During Periods of Precipitation (94-T-25F)
2003-01-08: Ignition Noise or Interference Heard Through the Radio Speakers (95-T-28A)
2003-01-08: Yellow Spots on the Seat Cushion or Seat Back Cover Surface (95-T-54A)
2003-01-08: Pressing any Button on Saturn RKE Fob, Sets Off Alarms on Some Automotive Security Systems (95-T-56)
2003-01-08: Service Information on Counterclockwise Rotation of A/C Compressor Clutch Drive Plate (96-T-01)
2003-01-08: Service Manual Update for the 1996 Revised Electrical Service Manual (96-T-22)
2003-01-08: Color Change to Fusible Link Circuit 2C From Starter Motor to Generator (96-T-56)
2003-01-08: MIL Service Engine Soon Light On with No Gear DTCs Present After Transaxle Assembly or Gear Sets Replacement (98-T-37)
2003-01-07: Erratic A/C and Power Steering Operation, Harsh Shifting with Auto Trans, ABS Telltale On and Traction Control Not Operating, and/or RKE Not Operating Correctly on Vehicles with RIA Cruise Control (95-T-41)
2003-01-07: During Special Test for Actuators the TFP and TCC Actuators Do Not Test Correctly (95-T-45)
2003-01-07: Service Manual Update for DTC P1380 (95-T-47)
2003-01-07: Service Manual Update on Transaxle Actuator Voltage Supply Circuit 458 (95-T-50)
2003-01-07: MIL On and DTC P0440 in PCM Memory (96-T-09A)
2003-01-07: Transaxle Intermittently Binds Going Into or Shifting Out of 1st and 2nd Gear, and/or is Stuck in 1st or 2nd Gear (96-T-07A)
2003-01-07: Cruise Control Drops Out Intermittently and/or May Not Set After Drop Out (96-T-13A)
2003-01-07: Information on Changes to Manual Transaxle Clutch Pressure Plate Cover Assembly and Clutch Driven Disc Assembly (96-T-16)
2003-01-07: MIL On and/or DTC P0141 Stored in PCM Memory (96-T-21A)
2003-01-07: Use of DEX-COOL Extended Life Engine Coolant for 1996 Interim Vehicles (96-T-23)
2003-01-07: Service Manual Update for 1996 Revised Powertrain Controls Service Manual (96-T-31)
2003-01-07: Knocking or Rattle Noise from Front of Vehicle During Deceleration (98-T-24A)
2003-01-07: ECT Sensor Related DTCs and/or the Following Condtions - Hard Start, Erratic Idle, Rough Running, Engine Overheating, Low and/or Leaking Coolant, and/or Service Engine Soon Lamp Illuminated (01-T-07)
2003-01-07: Intermittent Lack of Power and/or DTC P0326 (01-T-12)
2003-01-07: MIL Service Engine Soon Telltale is Illuminated With DTC P0401 (01-T-29)
2003-01-07: Service Information Regarding Upper Engine Mount Assembly (01-T-30A)
2003-01-06: Front Brake Noise and/or Front Brake Pulsation (96-T-40A)
2003-01-06: Design Changes to the Automatic Transaxle Torque Converter Housing and Oil Pump Wear Plate (96-T-41)
2003-01-06: Design Changes to the Automatic Transaxle Valvebody Cover Gasket, Valvebody Cover, Valvebody Cover Bolts and Transaxle Case (96-T-42B)
2003-01-06: Bolt Torque Retention Compound for Brake Caliper Support Bracket to Steering Knuckle Bolt (96-T-47)
2003-01-06: ABS Telltale Illuminated on Vehicles Equipped or Not Equipped with ABS, ABS DTC 11 or 12 May also Be Stored in Memory (96-T-49)
2003-01-06: Engine Cranks but will not Start, Engine Starts then Stalls, or Engine Surges or Stalls During Light Throttle Conditions and/or Engine Runs Rough, with Possible DTCs in PCM Memory (96-T-58)
2003-01-06: MIL On with DTC P0300 and Possible Pairs of DTCs P0301 and P0304, and/or P0302 and P0303 in PCM Memory (96-T-60)
2003-01-06: Service Manual Update for Automatic Transaxle Oil Pump Output Test and/or Line Pressure Test (96-T-64)
2003-01-06: Engine Coolant Recovery Reservoir Discoloration Due to Engine Cooling System Sealer (97-T-04A)
2003-01-06: Service Information on Automatic and Manual Transaxle Design Changes to the Differential Assembly Pinion Gear Shift (97-T-14)
2003-01-06: Service Information on New Oil Pump Cover (97-T-15A)
2003-01-06: Service Manual Update on Differential End Play Checking (97-T-19)
2003-01-06: MIL (Service Engine Soon Telltale Lamp) On and EGR DTCs P0401, P0404, P0405, P1404 and/or P1406 in PCM Memory (97-T-20A)
2003-01-06: MIL Service Engine Soon Light On with DTCs P0300 and/or P0301-P0304, Engine Misfire (97-T-30B)
2003-01-06: Resetting Crankshaft Adaptives and Performing Crankshaft Position Relearn Procedure (96-T-39)
2003-01-06: Engine Cooling System Sealer Usage (97-T-40A)
2003-01-06: Design Changes to Automatic Transaxle Control Solenoid Valve (97-T-41A)
2003-01-06: New Automatic Transaxle Clutch Plate Assemblies (97-T-48A)
2003-01-06: Service Information on 1996 Model Year Vehicles with Misfire Calibration Installed (97-T-49)
2003-01-06: MIL Service Engine Soon Light On with DTCs P0300 and/or P0301-P0304, Engine Misfire (98-T-14A)
2003-01-06: Quill Bearing Seal Protector Tool (J43270) (98-T-17)
2003-01-06: Pop Noise from Underbody After Vehicle is Parked or When Stationary at Idle (98-T-36)
2003-01-06: Information on Remanufactured Cylinder Head Assemblies Available for Service (98-T-44)
2003-01-06: MIL Service Engine Soon Telltale On with DTCs P0340 and/or P0341, Cam Sensor Circuit Performance (98-T-49A)
2003-01-06: New Special Tools (Go/No-Go Gauge P/No J43120 and J43481) Required for Cylinder Head Valve Guide (98-T-50)
2003-01-06: Service Manual Update Regarding Piston Installation (99-T-02)
2003-01-02: Frontal Supplemental Inflatable Restraint (SIR) Switch Kits (98-T-28)
2003-01-02: Audio System AM Band Radio Noise (98-T-43A)
2003-01-02: RKE or Security System Inoperative and/or Engine Will Not Crank, Power Door Locks Inoperative or Intermittently Inoperative, Power Windows Inoperative, Power Mirror Inoperative, Door Speaker Volume (99-T-43)
2003-01-02: Seat Belt Latch Falls to the Floor or is Difficult to Retrieve (01-T-44)
2003-01-02: SDM Connector Retainer (95-T-46)
2003-01-02: SIR Telltale Lamp ON with DTC 24 in SDM Memory (96-T-57B)
2003-01-02: Rattle or Buzz Noise Coming From the Instrument Cluster Assembly (96-T-63)
2003-01-02: Generator and Engine Wiring Harness Design Change (97-T-22)
2003-01-02: Battery and Generator Diagnostics (97-T-28)
2003-01-02: Request for Audio System Complaint Codes to be Added to Customer Service Order (CSO) (97-T-31)
2003-01-02: New RKE/SSS Module for Vehicles Equipped with RKE/SSS (97-T-44)
2003-01-02: Top Tether Hardware Package for Child Restraint Seats (97-T-47A)
2003-01-02: Engine will Not Crank, MIL and ABS Light On, Park Lamps Inoperative, Fuel Gage Inoperative, and/or Radio Speaker Inoperative (98-T-22)
2002-12-20: Sunroof Squeaks When Driving Over Rough Roads (00-T-58)
2002-12-19: Service Information for New Wagon Rear Seat Back Trim Covers and Pushpin Fasteners (00-T-35)
2002-12-19: Abnormal Wear or Cut on Inboard Edge of Seat Back Cover (00-T-38)
2002-12-19: Rattle Noise from Front of Dash Area (00-T-39)
2002-12-18: Service Information on New Torque Specification for Front Seat Adjuster to Vehicle Bolts (98-T-39)
2002-12-18: Sunroof Sunshade Fabric Material Separates From Sunroof Sunshade at Front and Rear Edges (98-T-47A)
2002-12-18: Headlamp Assemblies may Rattle and/or Vibrate (Add Rubber Shim to Headlamp Mounting Bracket) (98-T-46)
2002-12-18: Water Leaks onto Headliner (Replace Sunroof Housing Drain Hoses or Seal Sunroof Module) (98-T-48)
2002-12-18: Service Information for New 1991-1997 First Design Key (Square Head) Ignition Lock Cylinders (99-T-01)
2002-12-18: Exposed Carpet Edges at Door Openings (99-T-03)
2002-12-18: Vertical Swing Wires Protrude Through Front Seat Back Cover and Service Information on Design Changes on Replacement of Front Seat Back Covers (99-T-04)
2002-12-18: Procedure for Removal of Wagon Rear Wiper Arm When Held Onto Wiper Motor Shaft by Corrosion (99-T-06)
2002-12-18: Window Regulator Makes a Popping/Clicking/Binding Noise When Cycling Up or Down (99-T-18A)
2002-12-18: Repair Procedure for Stripped or Detached Front Seat to Floor Panel Attachments (99-T-21)
2002-12-18: Water Leaks onto Headliner (99-T-35A)
2002-12-18: Updated Service Information for Sectioning Rear Side Door Ring Lower Section and/or Outer Rocker Panel (99-T-48)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-05-30: Warranty Admin - ACDelco Remanufactured Transmissions (00-07-30-011)
2000-05-08: Info - Brake Fluid Level and Filling Recommendations (00-05-22-004)
1999-06-25: Warranty Admin - July 1999 Labor Time Guide Updates (99-00-89-010)
1999-05-25: Information - Original Equipment Chrome Plated Aluminum Wheel Identification (99-03-10-102)
1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
1999-03-09: Labor Time Guide Updates (99-00-89-003)
1999-03-04: Battery Insulator Replacement (99-06-03-002)
1999-02-26: Essential Tool J 42000 Battery Tester (99-06-03-001)
1999-02-19: Warranty Parts Center/Corporate Parts Return Program (40-05-01C)
1999-02-16: Warranty Administration - Labor Time Updates (99-00-89-001)
1998-08-01: SATURN: REAR LICENSE PLATE RATTLES WHEN CLOSING REAR COMP (98-T-04A)
1998-06-22: 1991 - 1997 POWERTRAIN CONTROL MODULE (PCM) & ANTILOCK BRAKE (96-T-46B)
1998-04-24: IGNITION STATIC NOISE HEARD THROUGH RADIO SPEAKERS (98-T-19)
1998-04-01: CREAK IN REAR WINDOW (BACK GLASS) AREA (97-T-09A)
1998-04-01: RATTLE IN ENGINE COMPARTMENT AT IDLE (97-T-13A)
1998-02-24: DOOR WINDOW GLASS WILL NOT GO UP OR DOWN (98-T-12)
1998-01-27: SATURN: RATTLE OR CLICK NOISE FROM REAR OF VEHICLE (98-T-07)
1998-01-27: SATURNS: CLUNK RATTLE, OR BUZZ NOISE COMING FROM FRONT (98-T-08)
1998-01-27: SUNROOF SHADE BINDS /RATTLES IN TRACKS AND OR SUNROOF (97-T-25A)
1997-11-01: SIR TELLTALE LAMP ON WITH DTC 24 IN SDM MEMORY (96-T-57A)
1997-10-24: INFO ON TOWING SATURN CARS WITH 4 WHEELS (97-I-19)
1997-10-24: 'HOOT' OR 'MOAN' NOISE DURING STEADY THROTTLE (97-T-46)
1997-10-01: KNOCKING OR RATTTLE NOISE AT RIGHT FRONT OF FLOOR TO FRONT (97-T-39)
1997-08-14: DOME LAMP ON AT ALL TIMES OR INTERMITT. (97-T-34)
1997-07-24: MIL (SERVICE ENGINE SOON TELLTALE LAMP) (97-T-29)
1997-07-01: AFTERMARKET CASSETTE- TYPE PORTABLE CD ADAPTERS (95-T-08B)
1997-06-04: SERVICE INFO ON INSTALL SERVICE MAIN BODY WIRE HARNESS (97-T-24)
1997-06-01: SERVICE INFORMATION ON NEW OIL PUMP COVER (97-T-15)
1997-05-01: ABS DTC'S 34 OR 35 (POSSIBLY WITH ABS DTCS 27 OR 28) (96-T-17A)
1997-04-01: CREAK IN REAR WINDOW (BACK GLASS) AREA (97-T-09)
1997-03-06: INTERMITTENT HOP OUT OF 5TH GEAR OR NO 5TH GEAR (97-T-06)
1997-03-05: SERVICE INFORMATION ON NEW EXHAUST MANIFOLD GASKET (97-T-07)
1997-03-03: TRANSAXLE BUMPS AND/OR MAKES A RATCHETING SOUND (97-T-05)
1997-01-29: AIR BAG TELLTALE ON WITH DTC 61 IN SENSING & DIAGNOSTIC (97-T-03)
1996-11-01: SERVICE TECHNICAL 15-DAY PROG. 1ST QUARTER CLASS SCHEDULE (96I24)
1996-10-21: MIL (SERVICE ENGINE SOON LAMP) ON WITH ONLY DTC P0741 IN PCM (96-T-61)
1996-10-21: RKE INOPERATIVE AT TEMPERATURES ABOVE 36 (96-T-62)
1996-10-15: 1996 OWNER'S HANDBOOK REVISIONS (96-I-23)
1996-10-11: SIR TELLTALE LAMP ON WITH DTC 24 IN SDM MEMORY (96-T-57)
1996-10-01: TECHNICAL ASSISTANCE CENTER (96-I-16)
1996-10-01: SATURN R.I.A. SECURITY SYSTEM (96-PA-12)
1996-10-01: SERVICE PARTS OPERATIONS (SSPO) SUPPLIER CONTACTS (96-PA-11)
1996-10-01: SERVICE INFO. ON DESIGN CHANGES TO AUTOMATIC TRANS. (96-T-42A)
1996-09-05: CORE PARTS RETURN & FAILED PARTS RETURN PROGRAMS (96-T-51)
1996-09-04: ELECTRICAL ACCESSORIES INTERMITTENTLY INOPERATIVE (96-T-50)
1996-09-01: SVCS. TECH. (15-DAY) PROGRAM, 4TH QTR., CLASS SCHEDULE (96-I-18)
1996-09-01: USED CAR CERTIFICATION ELIGIBLE MODEL YEARS (96-I-19)
1996-09-01: PARTS DEPOT (96-PA-09)
1996-09-01: PREMIUM CHARGE FOR OUT-OF-COMPLIANCE LOW STOCKING (96-PA-10)
1996-08-06: FRONT SIDE MARKER/TURN SIGNAL/ PARK LAMP RUBS PAINT (96-T-45)
1996-08-01: CHG. IN POLICY FOR MANAGING CAMPAIGN VEH. ACTION REPORTS (96-I-15)
1996-08-01: RETAIL PARTS COMMUNICATIONS & REFERENCE TOOLS (96-PA-08)
1996-07-26: FLUID LEAKS FROM AUTOMATIC TRANSAXLE END COVER ASSEMBLY (96-T-43)
1996-07-26: VEHICLE RUNS OUT OF FUEL WITH 1/8 TO 1/4 OF FUEL (96-T-44)
1996-07-26: SERVICE INFO. ON DESIGN CHANGES TO AUTOMATIC TRANS. (96-T-42)
1996-07-01: NEW SATURN FULFILLMENT SUPPLIER (96-F-04)
1996-07-01: CALIFORNIA VEHICLE CODE REQUIREMENTS RE:TIRE CHAIN (96-I-13)
1996-06-28: NEW FRONT DISC BRAKE PADS AND FRONT BRAKE ROTORS (96-T-40)
1996-06-13: REAR PASSENGER FOOTWELL CARPET WET (96-T-37)
1996-06-05: STEERING WHEEL HUB SEIZES TO STEERING COLUMN (96-T-36)
1996-06-03: SQUEAKS & RATTLES COMING FROM TOP OR TOP CORNERS (96-T-33)
1996-06-01: CLICKING OR TICKING FROM INSTRUMENT CLUSTER (95-T-27A)
1996-05-31: SQUEAKS & RATTLES COMING FROM SUNROOF (REPAIR WITH FELT KIT) (96-T-30)
1996-05-31: SUNROOF OPERATES SLOW, BINDS OR BECOMES INOPERATIVE (96-T-29)
1996-05-30: ENGINE RUNS ROUGH, SURGES AT IDLE, STALLS AFTER START (96-T-32)
1996-05-07: WHINE/RATTLE NOISE COMING FROM TRANSAXLE (96-T-26)
1996-05-07: DOME LAMP FALLS OUT OF HEADLINER (96-T-28)
1996-05-01: USED CAR INSPECTION TOOL KIT (96-I-08)
1996-05-01: FUEL FIX ALLOWANCE (96-I-10)
1996-05-01: CORE RETURN PROGRAM (96-PA-04)
1996-05-01: NEW KEY CODE BOOK (96-I-03A)
1996-04-18: ENGINE CRANKS BUT WILL NOT START, OR ENGINE STALLS (96-T-25)
1996-04-04: RECYCLING OF SATURN EXTENDED LIFE ENGINE COOLANTS (96-I-05)
1996-04-01: LEMON LAW (96-F-02)
1996-04-01: SATURN SERVICE PARTS OPERATION MATERIAL RETURN (96-PA-02)
1996-04-01: TWICE A WEEK REPLENISHMENT TO MAX PROGRAM (96-PA-03)
1996-04-01: DEX-COOL EXTENDED LIFE COOLANT (96-PA-05)
1996-04-01: 1996 MODEL PAINT INFORMATION (95-I-18A)
1996-03-28: MIL ON AND/OR DTC P0141 STORED IN PCM MEMORY (96-T-21)
1996-03-01: SERVICE TECH. TRAINING, 2ND QTR, CLASS SCHEDULE (96-I-04)
1996-02-20: CRUISE CONTROL DROPS OUT INTERMITTENTLY (96-T-13)
1996-02-01: CAMPAIGN: ROOF PANEL ASSEMBLY (96-C-01)
1996-01-23: MALFUNCTION INDICATOR LAMP ON & DIAGNOSTIC TROUBLE CODE (96-T-09)
1996-01-22: TRANSAXLE INTERMITTENTLY BINDS (96-T-07)
1996-01-19: RATTLE NOISE IN 2ND GEAR DURING LEFT HAND TURNS (96-T-06)
1996-01-01: WATERLEAK A RIGHT AND/OR LEFT FRONT FOOTWELL AREA (93-T-16B)
1996-01-01: LAUNCH OF SERVICE PLAN - CAR CARE COVERAGE (94-F-21C)
1996-01-01: EXPANDED TECHNICAL ASSISTANCE CENTER HOURS OF OPERATIONS (96-I-01)
1996-01-01: CERTIFIED USED CAR INSPECTION TRAINING PROGRAM (96-I-02)
1996-01-01: WATER LEAK AT FRONT UPPER DOOR FRAME (94-T-52A)
1995-11-01: 1996 SERVICE TECHNICAL TRAINING, FIRST QUARTER (95-I-22)
1995-11-01: INFORMATION ON AUTOMATIC TRANSAXLE CLUTCH PLATE (95-T-43B)
1995-09-18: MIXING GM DEX COOL (TM) (95-I-20)
1995-09-01: SERVICE PLAN HIGHLIGHTS (95-F-12)
1995-08-23: DOCUMENTATION FOR CANADIAN SATURN VEHICLES BROUGHT INTO (95-F-11)
1995-08-04: CALIFORNIA VEHICLE CODE REQUIREMENTS (95-I-13)
1995-08-04: PRE-SALE AVAILABILITY OF WARRANTY TERMS (95-I-14)
1995-08-03: INFORMATION ON NEW TORQUE SPECIFICATIONS (95-T-35)
1995-08-02: OWNER PROTECTION PLAN HIGHLIGHTS (95-F-10)
1995-08-01: MONEYBACK GUARANTEE PROGRAM POLICIES (95-I-15)
1995-08-01: CENTER ARM REST VERBIAGE IN 1996 OWNER'S HANDBOOK (95-I-16)
1995-08-01: NEW PRODUCT UPDATE CONTINUOUS LEARNING SEMINAR (95-I-17)
1995-08-01: SERVICE PARTS OPERATIONS PERSONNAL LISTING (95-PA-10)
1995-06-01: SERVICE INFORMATION ON COATED BRAKE ROTORS (95-I-11)
1995-06-01: MODEL YEAR PARTS ROLL-OUT (95-PA-08)
1995-05-10: EMISSION REQUIREMENTS (95-I-09)