Technical Service Bulletins

2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-25: Updated Warranty and Goodwill Exchange Program for Electronic Products (08-08-44-029)
2008-09-23: Special Coverage Adjustment - Analog OnStar Deactivation (08089B)
2008-09-22: Information on Upgrading Certain OnStar Analog/Digital-Ready Systems to OnStar Generation 6 Digital-Capable System (05-08-46-006P)
2008-09-19: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords blue button communication message no noconnect operation (PIC4600A)
2008-09-18: Information on OnStar Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
2008-09-17: GM Tire Warranty Program Claims Submission Changes (U.S. Only) (08-03-10-012)
2008-09-15: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including the Chevy Bowtie (06-08-111-004A)
2008-09-11: Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as Upsized to Original Equipment (05-03-10-005D)
2008-09-05: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses (02-08-42-001C)
2008-08-29: Car and Truck Fix It Right the First Time Issues (08-00-89-029A)
2008-08-29: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. and Canada Only) (07-03-10-016C)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-26: Radio Unlock Code Process for 1991-05 Saturn Models - keywords accessory activation body code disabled delco information inoperative lock number panasonic phone program theft radio security support (PIC4837B)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-14: Information on Aftermarket Device Interference with OnStar Diagnostic Services (08-08-46-004)
2008-08-13: Radio Unlock Code Process For 1991-2005 Saturn Models - keywords accessory activation body disabled delco information inoperative lock number panasonic phone program theft radio security support (PIC4837A)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-06: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022E)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative steering wheel (PIC4820A)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-07-17: Essential Service Tool update #4 (U.S. Retailers Only) (08-00-89-025)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-23: Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-17: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy (05-00-89-072B)
2008-06-17: Disc Brake Warranty Service and Procedures - LRO, Lateral Runout, Rotor, Corrosion, Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Squeak, Grind, Groan (05-05-22-002D)
2008-06-16: Questions Regarding Installation Of Dealer Installed Accessories (PIT3099D)
2008-06-11: Unwanted Repeated Calls to OnStar / Replace VCIM - keywords call letter mail phantomcall phone repeat (PIC4893)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors (07-08-64-022A)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-29: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory (08-06-03-005)
2008-05-22: IPC Odometer Programming Method Quick Reference Guide (07-08-49-020B)
2008-05-22: Information on Slight Vehicle Movement in Park at Start Up After Cold Soak (08-07-30-026)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-15: Essential Service Tool Update #2 (U.S. Retailers Only) (08-00-89-020)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-30: Diagnostic Trouble Codes (DTCs) Required on Repair Orders (06-00-89-050B)
2008-04-24: Parts Restriction on Ordering XM Digital Radio Receiver (03-08-44-022E)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-17: Being Prepared for TAC, Caller Preparedness - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics (08-00-89-014)
2008-04-17: Electronic Exchange Program Goodwill Procedures (05-00-89-045A)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-04: Battery Electrical Drain / Parasitic Load Test - keywords 8 ab astra aura dead drain draw drop electrical gmt201 gmt960 gmx001 gmx002 ion outlook pic4790 pic4790a pic4798 resistor saturn voltage vue (PIC4790A)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-31: Radio Unlock Code Procedure - keywords accessory activation body code disabled delco information inoperative number panasonic phone program security support theft theftloc (PIC4837)
2008-03-31: Escalation Process for Critical Orders for Electronic Service Center (ESC) Parts (06-00-89-032A)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-25: Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
2008-03-19: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication failedtovoice information intermittent OPC operation no noconnect performance (PIC4310B)
2008-03-14: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative operation onstar steering wheel (PIC4820)
2008-03-11: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006D)
2008-03-05: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital incoming noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393G)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-28: Battery Electrical Drain / Parasitic Load Test - keywords dead draw drop resistor voltage (PIC4790)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-25: General Motors Position Statement on Installation of Used, Salvaged or Imitation Air Bag System Components (08-09-41-003)
2008-02-19: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-006)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-06: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078B)
2008-02-05: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
2008-02-05: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience (04-06-01-029B)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-02-01: Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
2008-02-01: Distortion in Outer Surface of Vehicle Glass (00-08-48-005C)
2008-02-01: Information on Eliminating Noise in Audio System When Using Portable Playback Device (06-08-44-015A)
2008-01-31: Vibration Analysis Worksheet (03-00-91-001D)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-25: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
2008-01-23: 18 Digit Snapshot/Charge Summary Code No Longer Required for A/C Refrigerant System repairs Submitted for Warranty Reimbursement (05-01-38-008B)
2008-01-18: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-17: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-003)
2008-01-17: Re-establishing Communications with OnStar Center After Battery Disconnect (00-08-46-004C)
2008-01-17: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007D)
2008-01-15: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003C)
2008-01-15: GM Technical Assistance Information Form (TAC) and Service Strategy Process Utilizing Customer Service Comeback Prevention, Strategy Based Diagnostics (SBD) and Intermittent Concern Diagnosis (01-00-89-011g)
2008-01-09: Availability of GM OnStar Vehicle Diagnostics and GM Goodwrench Remote Diagnostic Services (06-08-46-002B)
2008-01-09: Seat Belt Extender Availability (99-09-40-005E)
2008-01-09: Information on Tire Radial Force Variation (RFV) (00-03-10-006C)
2008-01-09: OnStar Labor Operation Codes (05-08-46-005B)
2008-01-08: Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems (02-08-44-007C)
2008-01-08: OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System (05-08-46-004B)
2008-01-08: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call (02-08-46-006C)
2008-01-07: Tire Puncture Repair Procedures for All Cars and Light Duty Trucks (04-03-10-001D)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2007-12-27: Intermittent Current Or History DTC B2476 In OnStar GEN 5 6 Or 7 VCIM - keywords B2476 blue button call communication data digital information keypad led onstar OPC operation red (PIC4574A)
2007-12-17: Warranty Parts Center/Corporate Parts Return Program (99-00-89-019E)
2007-12-13: Essential Service Tool Update #8 (U.S. Retailers Only) (07-00-89-061)
2007-12-10: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) (03-06-04-030F)
2007-12-06: Chrome Wheel And Trim Corrosion - keywords body door molding tire warranty (PIT4548)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-30: OnStar Unwanted or Phantom Phone Calls - keywords call handsfree intermittent mmute OnStar OPC performance phantomcalls unwanted (PIC3278C)
2007-11-29: GWM Warranty Parts Center Return Program (05-00-89-042C)
2007-11-21: Release of DEXRON-VI Automatic Transmission Fluid (ATF) (04-07-30-037D)
2007-11-19: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007C)
2007-11-13: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-056)
2007-11-13: GM Training: 2008 Service Training Standards (STS) Updates (U.S. Dealers) (07-00-89-055)
2007-11-12: Customer Concern Not Duplicated/Verified Labor Operations (06-00-89-026A)
2007-11-09: Underbody Corrosion - keywords appearance body frame rust (PIT3749B)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008D)
2007-11-02: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication digital failedtovoice information intermittent OnStar OPC operation no noconnect (PIC4310A)
2007-10-31: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital information noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393F)
2007-10-24: Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
2007-10-23: Information on Proper Tire Pressure (00-00-90-002I)
2007-10-11: Odometer Reads 0 Miles (0km/h) Or B1001 after Programming The BCM - keywords calibration communication data lamp light no SDM SIR (PIT3969A)
2007-10-05: Disabled Onstar System Identification (PIC3597D)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-10-01: Information on 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shift, Slip, No Drive/Reverse (07-07-30-025)
2007-10-01: Intermittent Red LED DTC B2470 And Possible Unable To Contact OnStar Center - keywords analog blue button connect digital DTC information LED no OPC operation performance UE1 (PIC3341D)
2007-09-28: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
2007-09-21: Horn Inoperative Weak Or Muffled - keywords horn inoperative JB operation performance (PIC4621)
2007-09-21: Essential Service Tool Update #6 (U.S. Retailers Only) (07-00-89-049)
2007-09-21: Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires (03-03-10-007C)
2007-09-18: OnStar Gen 6 With A Current DTC U1500 - keywords blue button call cellular communication data digital DTC LED information noconnect onstar operation program PIC3718 PIC3718A tech2 UE1 U1500 vs3bgen6 (PIC3718D)
2007-09-17: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016A)
2007-09-14: GM Training: FINAL REMINDER - Hybrid Two-Mode Training Information (U.S. Dealers) (07-00-89-046)
2007-09-14: GM Training: September 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-045)
2007-09-12: No Communication with VCIM After TIS2WEB Service Programming System (SPS) - keywords communication message no noconnect onstar operation vs3bgen4 vs3bgen5 vs3bgen5 vs3bgen6 vsb3gen7 SPS (PIC4609)
2007-09-05: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
2007-08-29: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords B1000 blue button communication DTC information message no noconnect OnStar operation (PIC4600)
2007-08-23: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors (07-00-89-043)
2007-08-16: Warranty Admin. - Courtesy Transportation and Roadside Assistance Programs (07-00-89-037)
2007-08-14: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016)
2007-08-10: OnStar Hands Free Calling Security Lock - Lost Pin Procedure - keywords blue button cellular free hand handsfree identification information inoperative lock number onstar OPC PIN security telephone (PIC4589)
2007-08-06: OnStar Reactivation For Daily Rental Vehicles Purchased At Auction - keywords button communication disabled information message no noconnect OnStar operation rental vs3bgen6 vs3bgen7 (PIC4583)
2007-08-02: OnStar Gen 6 With A Current DTC U1500 - keywords blue button call cellular communication data digital DTC led information noconnect onstar operation program red tech2 UE1 U1500 vs3bgen6 (PIC3718C)
2007-08-02: Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
2007-08-02: Warranty Admin. - GM Dealer Empowerment Program and Goodwill Procedures (05-00-89-055B)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-26: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022D)
2007-07-20: XM - Factory Kit RadioCompatibility - keywords DRR kit radio U1C UM7 UMS XM radio (PIC4575)
2007-07-19: Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
2007-07-19: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) (06-08-50-009B)
2007-07-19: Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
2007-07-10: Low Oil Pressure - Inspect Oil Filter For Damage - keywords adjuster after change engine hot idle indicator lamp lash lifter light LOF mechanical no noise rattle tick (PIP3859A)
2007-06-29: OnStar Handsfree Calling (OHFC) Inoperative And OnStar Blue Button Keypress Is Now Receiving The Demo Message - keywords 05-08-46-006M blue button communication digital disabled message no OnStar OPC (PIC4564)
2007-06-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for June, 2007 (06-00-89-041G)
2007-06-27: GM Training:Introducing 2007 Saturn Training Bonus (U.S. Dealers) (07-00-89-029)
2007-06-27: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 (07-01-38-004)
2007-06-27: GM Training:May 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-028)
2007-06-26: GM Training:April 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-025)
2007-06-26: GM Training:Service Training Standard (STS) Effective Date for Two Required Technology Close-ups (TCUs) was 04/14/07 (U.S. Dealers) (07-00-89-024)
2007-06-26: GM Training:Saturn Report Changes (U.S. Dealers) (07-00-89-017)
2007-06-26: GM Training:Announcing the 2008 Body Structural and Painting Service Training Standards (STS) Requirements for Saturn Dealers (U.S. Dealers) (07-08-51-002)
2007-06-26: GM Training:Number of Technicians Required Reduced for Two Categories (U.S. Dealers) (07-00-89-016)
2007-06-26: GM Training:Three Technology Close-Up IDL Seminars as New 2007 Service Training Standard (STS) Requirements (U.S. Dealers) (07-00-89-014)
2007-06-26: GM Training:March 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-013)
2007-06-26: GM Training:Course Information (For U.S. Dealers and Aftermarket) (07-00-89-011)
2007-06-26: GM Training:January 2007 GM Service Know-How Emerging Issues Seminar (#10207.01D) (For U.S. Dealers Only) (07-00-89-007)
2007-06-26: GM Training:Maintaining GM STC Master Technician Certification (MTC) (For U.S. Dealers Only) (07-00-89-005)
2007-06-26: GM Training:HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) (07-01-38-001)
2007-06-26: GM Training:Saturn Person Types Renamed on the GM Training Website (For U.S. Dealers Only) (07-00-89-006)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-22: Use of Silicone for Weatherstrip Maintenance (99-08-64-016B)
2007-06-21: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage (00-06-01-026B)
2007-06-18: Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
2007-06-14: Communication Strategy of Service Information/Strategy Based Diagnostics (05-00-89-067B)
2007-06-12: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT - CH-47976) (03-06-04-030E)
2007-06-08: Windshield Wiper Performance, Cleaning Instructions and Maintenance (06-08-43-003A)
2007-06-06: Timing Belt Replacement - keywords belt cam camshaft crank crankshaft engine gear L81 mark new part replacement teeth timing (PIP3933A)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-31: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital information noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393E)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: OnStar DTC U1000 After ADT Kit Installed - keywords analog digital inoperative led order parts program red tech2 u1000 upgrade vs3bgen4 vsbgen5 vs3bgen6 (PIC4526)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-24: Corrosion Protection for Metal Panels with Dealer Installed Accessories Fastened by Drilled Holes (03-00-89-008C)
2007-05-23: Disc Brake Warranty Service and Procedures - LRO, Lateral Runout, Rotor, Corrosion, Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Squeak, Grind, Groan (05-05-22-002C)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-17: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-04-02: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair (07-08-98-001)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-13: Information on OnStar System - Possible Loss of GPS and/or Unable to Replenish Hands-Free Calling Minutes (02-08-46-007B)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-15: Info - New Bulletin Category: Technical Training (U.S. Only) (07-00-89-003)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-23: Info - Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-17: Info - Diagnostic Trouble Codes (DTCs) Required on Repair Orders (06-00-89-050A)
2007-01-11: Digital Radio Receiver Rapid Activation Utilization - keywords diagnosis digital DRR exchange information lock module no number part radio receiver reception reman satellite U2K (PIC4374)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Parts Update - Timing Chain Tensioner Design Change - keywords adjuster after change chain chevrolet damage design engine filter hot idle indicator information lamp lash lifter light mechanical no (PIP4014)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2006-12-14: Info - Essential Service Tool Update #9 (U.S. Retailers Only) (06-00-89-056)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-27: Info - New Bulletin Categories (05-00-89-005A)
2006-11-17: Info - Essential Service Tool Update Number 8 (U.S. Retailers Only) (06-00-89-049)
2006-11-09: Crank No Start When Cold Due To Compression Loss - keywords cylinder cylinderhead extended hard head lifter loss (PIP3146B)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Product Safety - Ignition Control Module Replacement (03-C-06A)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Service VME - Additional Information About Passenger Presence Systems (PPS) - keywords bladder information passenger PPS presence restraint seat sensor SIR system weight (PIT4138)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-26: Repeat DTC P0606 And P1780 Setting - keywords 00 01 02 03 04 05 DTC JB L81 MAF MIL P0606 P1780 reducedpwrmde reman saturn (PIP3922)
2006-09-15: Information Regarding Updated PC Grade Specifications and Techline Support (U.S. Only) (06-00-89-045)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-08: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (06-08-111-004)
2006-09-07: Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-17: 4T65E Whine Noise Park/Neutral - keywords bearing drive sprocket support (PIP3894)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-05: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for May, 2006 (06-00-89-028)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Intermittent Neutral from a Stop or 2-3 Shift - keywords 4L60E 4L65E flare launch slip (PIP3002D)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-12: Odometer Reads 0 Miles (KM) or B1001 Set After Programming the BCM - keywords calibration communication data lamp light no SDM SIR (PIT3969)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-31: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for March, 2006 (06-00-89-017)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-07: Intermittent No Crank, No Start (Clean Battery Side Terminal Stripped Threads, Replace Battery Cable Bolt) (02-06-04-015A)
2006-03-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for February, 2006 (06-00-89-012)
2006-02-24: Service VME - Underbody Corrosion - keywords appearance body frame rust (PIT3749A)
2006-02-24: Questions Regarding Installation of Dealer Installed Accessories - keywords 2.8 3.5 4.2 4.8 5.3 6.0 8.1 accessory part Partech (PIT3099C)
2006-02-13: Info - Radio Knobs Available for Service (05-08-44-029A)
2006-02-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for December, 2005 and January, 2006 (06-00-89-007)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-27: Info - Essetnial Service Tool Update No. 1 (U.S. Retailers Only) (06-00-89-005)
2006-01-04: SMU - Revised Passenger Compartment Air Filter Replacement (06-01-37-001)
2006-01-04: Unable to Connect to OnStar or OnStar Personal Calling Inoperative in Alaska Only (Cancel Corporate Bulletin Number 05-08-46-002A) (05-08-46-002B)
2005-12-21: Info - Essential Service Tool Update No. 7 (U.S. Retailers Only) (05-00-89-087)
2005-12-09: Info - Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems (02-08-44-007B)
2005-12-08: Hesitation on Acceleration After Internal Engine Repairs - keywords fuel lean induced sag (PIP3648)
2005-12-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for November, 2005 (05-00-89-085)
2005-11-23: Info - Essential Service Tool Update Number 6 (U.S. Retailers Only) (05-00-89-081)
2005-11-21: Product Safety - Brake and/or Tail Lamps Inoperative (05052)
2005-11-18: Warranty Admin. - Warranty Parts Center/Saturn Parts Return Program Concerns (05-00-89-080)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-11-04: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for October, 2005 (05-00-89-077)
2005-11-01: Oil Leak from Engine Front Cover Crankshaft Oil Seal During Extremely Cold Weather (Replace Crankshaft Front Oil Seal) (04-06-01-009A)
2005-10-27: Radio Displays XM Error or DTC U1137 - keywords communication digital loss nocomm operation performance tech2 U2K (PIC3303A)
2005-10-26: Info - Transition of Saturn Technical Training to GM Service Technical College (STC) Training Program (U.S. Only) (05-00-89-073)
2005-10-03: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for September, 2005 (05-00-89-064)
2005-09-23: Info - Essential Service Tool Update Number 5 (U.S. Retailers Only) (05-00-89-063)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-09-12: Whine Noise after Water Pump Replacement - Proper Use of J43651 - keywords camshaft chain engine front repairs (PIP3535)
2005-09-09: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in July and August, 2005 (05-00-89-061)
2005-08-26: Info - Essential Service Tool Update #4 (U.S. Retailers Only) (05-00-89-058)
2005-08-26: Tick Noise from Engine - keywords 3.0 air click hydraulic knock lifter noise oil stick stuck (PIC3668)
2005-08-22: Warranty Admin. - Restriction on Battery Warranty Claims (05-06-03-006)
2005-08-11: Info - Pinstripe/Vinyl Graphic Installation Tips and Techniques (04-08-51-004A)
2005-07-21: Enhancement to Saturn Goodwill Rental Car Program (U.S. Only) (05-00-89-044)
2005-07-01: Info - Essential Service Tool Update Number 3 (U.S. Retailers Only) (05-00-89-040)
2005-07-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in June, 2005 (05-00-89-039)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-23: Warranty Admin. - GM New Vehicle Tire Warranty Program (U.S. Only) (05-03-10-009)
2005-06-02: Saturn Field Product Reminder-Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in May, 2005 (05-00-89-033)
2005-05-25: Compact Disc (CD) Player Inoperative - Will Not Load, Will Not Eject or Will Not Play (Remove Both Radio Fuses to Reset Radio) (04-08-44-018A)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-12: Recall 05041 Rear Seat Belt Reinforcement - keywords campaign restraint saturn seatbelt (PIC3547)
2005-05-12: Info - Service Support and Technical Assistance for OnStar and/or XM Radio (04-08-46-001A)
2005-05-12: Information on Service Support and Technical Assistance for OnStar (U.S. Only) (05-08-46-003A)
2005-05-10: FMVSS Noncompliance - Installation of Rear Seat Center Belt Anchor Reinforcement Plate (05041)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in April, 2005 (05-00-89-028)
2005-04-27: Info - Labor Time Guide Requests for Review (U.S. Retailers Only) (05-00-89-026)
2005-04-26: Info - XM Radio Labor Operation Codes (03-08-44-001A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-15: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in February and March, 2005 (05-00-89-016)
2005-03-10: Warranty Admin. - New Definition for Parts Warranty Case Type (05-00-89-015)
2005-02-23: Service Information Regarding Timing Belt Coolant Contamination (05-06-01-008)
2005-02-23: Info - Extended Warranty Available for Saturn Tech 2 Scan Tools (05-00-89-010)
2005-02-11: Quick Tips for Warranty Administration (05-00-89-007)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-02: Insufficient Heat, Service Engine Soon (SES) Light On, DTC P0128 Set (Replace Thermostat Assembly) (03-06-02-002A)
2005-02-02: Power Steering System Noise and/or Leak Diagnosis (02-02-32-009A)
2005-01-31: Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Bulletins Released in December 2004 and January 2005 (05-00-89-004)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-18: Service Wrench and SES Telltale May Be Illuminated and Transaxle May Shift Harshly - kw 4T40E 4T45E code U2103 U2104 U2105 transmission harsh (PIP3295)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2004-12-06: Service Engine Soon (SES) Telltale Illuminated with Diagnostic Trouble Codes (DTCs) P0171, P0172, P0174 and/or P0175 (Refer to Diagnostic Procedure in this Bulletin, Replace Mass Air Flow (MAF) Sensor (01-06-04-016A)
2004-11-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in November 2004 (04-00-89-058)
2004-11-22: Service Engine Soon (SES) and/or Reduced Power Lamp Illuminating Following Cold Engine Start Up In Subfreezing Temperatures with Diagnostic Trouble Codes (DTC) P0638, P1510 and/or P1516 Stored in ECM (04-06-04-085)
2004-10-26: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in October, 2004 (04-00-89-048)
2004-10-20: Info - New Measuring Wheel Alignment Procedure for Labor Operation Numbers E2020 and E2000 (04-03-07-003)
2004-10-19: Service Engine Soon Lamp Illuminated with DTCs P0130, P0135, P0150 and/or P0155 (Perform Oxygen Sensor Conditioning Drive Cycle) (04-06-04-008A)
2004-10-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in September 2004 (04-00-89-044)
2004-09-28: Steering Wheel Shake or Vibration at Highway Speeds (Balance Tire/Wheel Assemblies, Replace Front Lower Control Arm Rear Bushings, Replace Steering Gear Preload Spring and Replace Tires, If Necessary) (99-00-91-002E)
2004-09-24: Fuel Gauge Displays an Erratic or False Reading or No Start Condition after Vehicle is Shut Off with Low Fuel Level (Diagnose Fuel Gauge and Fuel Sender and/or Adjust/Replace Fuel Sender) (03-08-49-022B)
2004-09-22: Clunk Noise from Front of Vehicle During Turning Maneuver/Steering Wheel Rotation (Lubricate Intermediate Shaft) (04-02-35-008A)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: Information on Intermittent Dimming (Flickering) of Headlamps and/or Instrument Panel Lighting - Normal Characteristics/No Service Required (04-08-42-001A)
2004-09-13: 01-05 Saturn 3.0 L, L81, (JB) and 02-03 Saturn VUE ( Z5 , Z6 ) Pop Noise from Engine Area during Heavy Throttle Input - kw clunk intake manifold accelerate pedal (PIP3135)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-08-30: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in August, 2004 (04-00-89-037)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-17: Popping/Crackling Noise or Distorted Sound from Speakers at Low Volume When a Compact Disc (CD) is Played (Replace RPO U1C CD Player/Radio with New Design CD Player/Radio) (04-08-44-016)
2004-08-12: Routing the Longer Tuned Power Steering Hose Per TSB 03-02-32-045 - kw pressure moan groan noise 2.2 L61 install tune (PIP3099)
2004-08-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time issues, Parts Restriction Information and Technical Bulletins Released in June and July 2004 (04-00-89-031)
2004-07-08: 03 Saturn JB Brake Dust Difficult to Remove from Chrome Clad Wheels - kw wheel rim clean polish (PIC3040)
2004-07-07: All 00-04 JB Saturn L-Series except with Sunroof Dark Rectangles or Circles in Center of Roof - kw rust exterior magnet spot (PIC3036)
2004-07-07: All Model Year 00-04 Saturn JB L-Series Vehicles Thump Noise/Vibration Flat Spotted Tires on Vehicle - kw suspension wheel (PIC3037)
2004-07-07: 03-05 Saturn L Series Sedans Lower Edge of the Rear Fascia Is Not Even - kw sag bumper fit (PIC3039)
2004-07-02: Info - Return Form for Compact Discs (CDs) or Digital Versatile Discs (DVDs) That Are Stuck in CD Player When Returned as a Core Return (04-08-44-015)
2004-06-22: Theft Deterrent Feature Will Not Set On Cassette Single CD Player Radio (RPO UP0) (Replace Radio) (04-08-44-013)
2004-06-17: Service Information Regarding Rear Seat Entertainment System (DVD) Diagnostics and Service Procedures (04-08-44-008A)
2004-06-15: Saturn Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information and Technical Bulletins Released in May, 2004 (04-00-89-023)
2004-05-06: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in April, 2004 (04-00-89-017)
2004-05-06: Information Regarding Air Conditioning (A/C) Compressor Noise at Engine Start (A/C or Defrost Mode Selected) or at A/C or Defrost Activation (After Engine Start) (04-01-37-005)
2004-04-30: Product Safety - Wiper Motor Replacement (03-C-03)
2004-04-28: Service Manual Update for Engine Block Clearance, Cylinder Head Clearance and Fastener Torque Specifications (04-06-01-011)
2004-04-22: Blue Smoke at Engine Start-Up (Inspect Valve Stem Seal Color and Perform Service Procedure) (04-06-01-010)
2004-04-22: Red OnStar LED , No Keypad Response When Pushed DTC B2476 - kw inoperative UE1 (PI02018)
2004-04-20: SMU - Add DTC P0504 (04-06-04-027)
2004-04-15: Information on Clicking Noise from Chrome Clad Wheels at Low Speeds - Normal Characteristic/No Service Required (04-03-10-003)
2004-04-15: Service Vehicle Soon Lamp Illuminated with Diagnostic Trouble Code (DTC) P1811 Maximum Adapt and Long Shifts (Inspect Transaxle and Replace Pressure Control Solenoid) (04-07-30-020)
2004-04-15: Service Manual Update Regarding Headlamp Alignment (04-08-42-007)
2004-03-30: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in January, February and March 2004 (04-00-89-012)
2004-02-26: Low Volume Ticking Noise, Radio Volume Resolution, Clock Not Keeping Correct Time or CD Will Not Load/Eject (Replace Radio/Six-Disc In-Dash CD Changer Assembly) (03-08-44-019A)
2004-02-25: Automatic Climate Control Overcompensation (Verify Automatic Climate Control Functions and Review Customer Information) (04-01-39-001)
2004-02-20: 4L60E , 4L65E No 2nd , No 4th and No Reverse - automatic fourth second shift transmission (PI00822C)
2004-01-30: Information on Intermittent Dimming (Flickering) of Headlamps and/or Instrument Panel Lighting - Normal Characteristic/No Service Required (04-08-42-001)
2003-12-19: Compact Discs (CDs) Skip In Single CD Player (Replace Radio Assembly) (03-08-44-016A)
2003-12-08: Service Manual Update Regarding a Change in the Defrost Operation for the Automatic Climate Control (03-01-39-015)
2003-10-21: Little or No Windshield Washer Solvent coming from Washer Nozzles (Reposition the Inline Connector) (03-08-43-005)
2003-10-02: Service Engine Soon (SES) Light On, Torque Converter Clutch (TCC) Stuck On, Diagnostic Trouble Code (DTC) P0742 (Replace TCC Solenoid) (03-07-30-046)
2003-09-26: Info - Oil Filter Cap Assembly and Oil Filter Element Design Change (03-00-90-003)
2003-09-25: Moan or Groan Noise While Turning Steering Wheel at Low Speeds (Install Tuned Power Steering Pressure Hose) (03-02-32-045)
2003-09-16: SMU - DTC P1516 Diagnostic Flow Chart Revised Connector Callout (03-06-04-044)
2003-09-12: Rattle or Buzz Noise from Rear of Passenger Compartment (Install Foam Tape to Curtain Inflator (Side Airbag) Module) (03-09-41-004)
2003-09-11: Info - Changes to the U1C Radio On-Board Diagnostic Modes and CD Load Operation (03-08-44-017)
2003-09-11: (MIL) Service Engine Soon Telltale Lamp On, Reduced Power Lamp May Illuminate with DTCs P0121,P0221 and/or P2135 (Replace Throttle Body, Throttle Body Connector, Throttle Body Terminals and Install (03-06-04-043)
2003-08-29: Info - Clarification of Labor Codes Used for Reprogramming Vehicle Controllers (03-00-89-025)
2003-08-29: Intermittent Security Telltale Illumination and/or DTC B2960 (Replace Passlock Sensor) (03-08-56-002)
2003-07-29: Odor from A/C at Vehicle Start-Up (Remove Debris from Evaporator Case, Apply Cooling Coil Coating and Activate or Install Delayed Blower Motor Control Module) (03-01-39-012)
2003-07-17: Center Console Arm Rest Lid Contacts Lumbar Adjuster Knob (Remove and Reinstall Center Console) (03-08-49-011)
2003-06-26: Six-Disc Radio Will Not Load, Eject and/or Play Compact Discs (CDs) (Remove and Reinstall Radio Fuses) (03-08-44-010)
2003-06-09: Info - Timing Chain Design Change and Revised Service Procedures (03-06-01-017)
2003-04-24: A/C System R-134a Refrigerant Ultra Vilet (UV) Dye Usage (02-T-75)
2003-04-24: Whistle Noise from Power Steering While Turning Left (02-T-77)
2003-04-24: Placement of Vehicle Model Badges on Decklid Applique or Liftgate (01-T-36A)
2003-04-23: Service Information Regarding Redesigned Wiper Linkage and New Service Procedures (02-T-62)
2003-04-17: New Design Line Pressure Control Solenoids (02-T-44)
2003-04-17: Hood Prop Rod Contacts Hood Release Cable when in Stowed Position (02-T-55)
2003-04-16: DVD Player Will Not Accept Disc (02-T-87)
2003-04-16: Loose or Torn Seat Covers (03-T-03)
2003-04-08: Info - Design Changes to Reverse Clutch and Related Components on Automatic Transaxles (MN4 and MN5) (03-07-30-009)
2003-03-25: Intermittent Operation of Tailgate Release Button (Replace Switch Lever and Compression Spring Washer) (03-08-66-004)
2003-03-07: Bumps or Iron Dust on Paint Surface (Apply Buffered Oxalic Acid Spray or a Clay Type Non-Acid Based Product Using Manufacturers Recommendations) (99-08-51-006C)