Technical Service Bulletins

2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-29: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process -For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB,Audio, Display, Map Concerns (08-08-44-010D)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-26: Steering and Front Suspension Noise Concerns - Clunk, Thump, Rattle, Knocking, Pop, Shudder, Vibration (Diagnosis and Perform Necessary Repair) (04-03-08-006C)
2008-09-25: Updated Warranty and Goodwill Exchange Program for Electronic Products (08-08-44-029)
2008-09-22: Rear Defogger Grid Inoperative or Incomplete Defogging of Rear Glass (Repair Broken Defogger Grid Wires) (05-08-48-003C)
2008-09-19: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords blue button communication message no noconnect operation (PIC4600A)
2008-09-18: Information on OnStar Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
2008-09-18: DVD Navigation Update Program, AVN Software Update Discs and Ordering Information (06-08-44-012C)
2008-09-17: GM Tire Warranty Program Claims Submission Changes (U.S. Only) (08-03-10-012)
2008-09-15: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including the Chevy Bowtie (06-08-111-004A)
2008-09-11: Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as Upsized to Original Equipment (05-03-10-005D)
2008-09-05: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses (02-08-42-001C)
2008-09-02: HIGH SPEED LAN Diagnostics / Remembering Ohms Law (PIC4957)
2008-08-29: Car and Truck Fix It Right the First Time Issues (08-00-89-029A)
2008-08-29: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. and Canada Only) (07-03-10-016C)
2008-08-28: GM Training - September 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-10-89-032)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-26: SES Light and DTC P0230 (PIP4462)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-22: Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns (08-06-03-009)
2008-08-21: Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up (06-08-47-001E)
2008-08-15: No ISS Signal at Low Speeds - keywords dtc input mil no sensor ses speed transaxle (PIP4453)
2008-08-14: Information on Aftermarket Device Interference with OnStar Diagnostic Services (08-08-46-004)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-06: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022E)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: OnStar Turn By Turn / TBT Feature Inoperative - keywords blue button calibration call cellular communication data digital navigation operation performance (PIC4801A)
2008-08-01: Continuous OnStar Progression Tones AFTER Call End Attempt Is Made - keywords battery blue button DTC emerging flashes inoperative issue led mute no noconnect radio red (PIC4500C)
2008-07-30: Transmission Fluid Leak, Slipping Clutch or Broken Axle Shaft - keywords crack housing shift slip (PIP3932B)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-24: EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17 - Diagnostic Information to Reduce Vibration Concerns) (07-03-10-013C)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-21: Transmission Fluid Leak Slipping Clutch Or Broken Axle Shaft - keywords crack housing shift slip (PIP3932A)
2008-07-21: GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) - (This in not a Saturn STS Requirement) (08-00-89-027)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-07-17: Essential Service Tool update #4 (U.S. Retailers Only) (08-00-89-025)
2008-07-16: Noise From rear Of Vehicle During Cold Start - Potential Noise Characteristic - keywords BQMI (PIC4317D)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-26: Intermittent SES Light Due To A P0442 With No EVAP Leaks - keywords BQMI (PIP4431)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-23: Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: Enhancing Field Product Reports with Digital Pictures (07-00-89-036A)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-17: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy (05-00-89-072B)
2008-06-17: Disc Brake Warranty Service and Procedures - LRO, Lateral Runout, Rotor, Corrosion, Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Squeak, Grind, Groan (05-05-22-002D)
2008-06-16: Questions Regarding Installation Of Dealer Installed Accessories (PIT3099D)
2008-06-11: Unwanted Repeated Calls to OnStar / Replace VCIM - keywords call letter mail phantomcall phone repeat (PIC4893)
2008-06-11: GM Training:June 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-022)
2008-06-06: Check Engine Light On, DTCs P0171, P0300, P1174 Set (Perform Injector Test, Replace Injectors and Reprogram ECM, if Necessary) (08-06-04-001A)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: Surge On Light Throttle/Slight Inclines After Torque Converter Clutch (TCC) Engagement In Third or Forth Gear (Reprogram TCM) (08-07-30-029)
2008-06-05: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors (07-08-64-022A)
2008-06-05: OnStar Deactivated Returned To Stock New Vehicle Inventory - keywords activation button deactivated disabled inventory keypress letter (PIC4889)
2008-06-03: Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-29: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory (08-06-03-005)
2008-05-22: IPC Odometer Programming Method Quick Reference Guide (07-08-49-020B)
2008-05-22: Information on Slight Vehicle Movement in Park at Start Up After Cold Soak (08-07-30-026)
2008-05-20: Audio Whine Noise from Radio Speakers When Using OnStar (Install Noise Suppression Filter) (07-08-46-002B)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-15: Essential Service Tool Update #2 (U.S. Retailers Only) (08-00-89-020)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: GM Training: May 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-019)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Required Return Criteria of Complete Electrical Centers (EC) and Body Control Modules (IBCMs) with Integrated Electrical Centers to Warranty Parts Center (WPC) (05-08-45-002D)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-02: Parts Restriction on Ordering OnStar Generation 6 and 7 Vehicle Communication Interface Modules (VCIM) (03-08-46-004D)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-30: Diagnostic Trouble Codes (DTCs) Required on Repair Orders (06-00-89-050B)
2008-04-28: Headliner Wet At Center Map Light/Sunroof Switch Area (Adjust Sunroof and Apply Lube) (06-08-67-019A)
2008-04-28: Information on Paint Stain Under Protective Shipping Film (05-08-51-001C)
2008-04-24: EI08085 - 2.0L, MIL Lamp On, DTC P0420, Exhaust Noise, Poor Engine Performance (Parts Restriction) (08-06-05-002A)
2008-04-24: Parts Restriction on Ordering XM Digital Radio Receiver (03-08-44-022E)
2008-04-24: PQC Part Restriction - Catalytic Converter Part Numbers 15147065 and 15873413 - keywords 08-06-05-002 dtc EI08085 engine exhaust information lamp light low MIL no noise p0420 performance poor power (PIP4391A)
2008-04-22: Intermittent SES Light Due To DTCs P060E P2135 And/Or P2138 (PIP4175E)
2008-04-21: 4T45E DTC P0843 - keywords MIL MN5 pressure release SES slip TCC (PIP4228A)
2008-04-21: GM Training: STS Report Change Effective April 19th 2008 (U.S. Dealers) (08-00-89-016)
2008-04-21: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-015)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-18: Onstar TBT (Turn by Turn) and Digit Dispays Location keywords call cellular comunication data digit digital hud information operation radio unable turn use (PIC4510A)
2008-04-17: Being Prepared for TAC, Caller Preparedness - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics (08-00-89-014)
2008-04-17: Electronic Exchange Program Goodwill Procedures (05-00-89-045A)
2008-04-17: Turn By Turn Will Not Cancel Route - keywords cancel navigation onstar voice rec TBT (PIC4596A)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-11: PQC Part Restriction - Catalytic Converter Part Numbers 15147065 and 15874313 - keywords 08-06-05-002 DTC EI08085 engine exhaust information lamp light low mil no noise P0420 performance poor power (PIP4391)
2008-04-10: Continuous OnStar Progression Tones AFTER Call End Attempt Is Made - keywords battery blue button DTC emerging flashes inoperative issue LED mute no noconnect radio red (PIC4500B)
2008-04-10: Intermittent Service Engine Soon (SES) Lamp Illumination During Light Throttle Operation, DTC P0843 (Inspect for Torn Torque Converter O-Ring) (08-07-30-018)
2008-04-10: Normal Operating Characteristics of Electric Power Steering (EPS) System During Extended Lock-to-Lock Turns (Maximum Steerign Wheel Rotation) and/or DTCs C0176 and C0476 Set (06-02-32-002C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-08: OnStar RPO Code Questions - keywords data digital information no option print (PIC4483A)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-04: Battery Electrical Drain / Parasitic Load Test - keywords 8 ab astra aura dead drain draw drop electrical gmt201 gmt960 gmx001 gmx002 ion outlook pic4790 pic4790a pic4798 resistor saturn voltage vue (PIC4790A)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-31: Escalation Process for Critical Orders for Electronic Service Center (ESC) Parts (06-00-89-032A)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-25: Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
2008-03-19: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication failedtovoice information intermittent OPC operation no noconnect performance (PIC4310B)
2008-03-19: Harsh TCC Apply Or Vibration In Active Fuel Management V4 Mode If Equipped With AFM - keywords converter shudder torque (PIP4371)
2008-03-12: P0833 And/Or Cruise Control Inop - keywords 5sp 6sp clutch code M12 zMM6 MZ6 M10 pedal switch transmission (PIP3673D)
2008-03-12: Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
2008-03-11: Intermittent No Connect Gen6 Gen7 Or Gen8 (PIC4551B)
2008-03-11: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006D)
2008-03-05: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital incoming noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393G)
2008-03-05: EI08085 - 2.0L, MIL Lamp On, DTC P0420, Exhaust Noise, Poor Engine Performance (Engineering Information) (08-06-05-002)
2008-03-04: Information OnStar Vehicles Unable To Receive Turn By Turn Directions - keywords calibration GPS navigation location radio route voice (PIC4801)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-29: Intermittent SES Light due to DTCs P060E, P2135, and/or P2138 - keywords chaff circuit connection controls ECM engine ground L61 LSJ no PCM shart solder wire wiring (PIP4175D)
2008-02-28: Battery Electrical Drain / Parasitic Load Test - keywords dead draw drop resistor voltage (PIC4790)
2008-02-27: Diagnostic Information for Inoperative Remote Vehicle Start (08-08-52-002)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-26: Audio Whine Noise from Radio Speakers When Using OnStar (Install Noise Suppression Filter) (07-08-46-002A)
2008-02-25: General Motors Position Statement on Installation of Used, Salvaged or Imitation Air Bag System Components (08-09-41-003)
2008-02-19: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-006)
2008-02-19: Moan Groan Noise From Manual Transaxle - keywords apply differential howl slip (PIP4349)
2008-02-15: Battery Part Restriction - keywords cable cell corrosion crank hard inoperative leak low no replace start (PIT4380B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-06: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078B)
2008-02-05: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
2008-02-05: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience (04-06-01-029B)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-02-05: Engine Oil Leak From Behind Starter Motor (Replace Oil Pressure Switch) (08-06-01-002)
2008-02-01: Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
2008-02-01: Distortion in Outer Surface of Vehicle Glass (00-08-48-005C)
2008-02-01: Information on Eliminating Noise in Audio System When Using Portable Playback Device (06-08-44-015A)
2008-01-31: Noise From The Rear Of Vehicle - keywords canister cold CVS click evap knock L61 LE5 solenoid tick vent (PIC4317C)
2008-01-31: Vibration Analysis Worksheet (03-00-91-001D)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-25: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
2008-01-24: Intermittent SES Light Due To DTCs P060E P2135 And / Or P2138 - keywords chaff circuit connection controls ECM engine ground L61 LSJ no PCM short solder terminal wire wiring (PIP4175C)
2008-01-23: 16 Inch Accessory Wheels Available Through GM Accessories (05-03-10-001E)
2008-01-23: 18 Digit Snapshot/Charge Summary Code No Longer Required for A/C Refrigerant System repairs Submitted for Warranty Reimbursement (05-01-38-008B)
2008-01-18: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-17: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-003)
2008-01-17: Re-establishing Communications with OnStar Center After Battery Disconnect (00-08-46-004C)
2008-01-17: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007D)
2008-01-15: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003C)
2008-01-15: GM Technical Assistance Information Form (TAC) and Service Strategy Process Utilizing Customer Service Comeback Prevention, Strategy Based Diagnostics (SBD) and Intermittent Concern Diagnosis (01-00-89-011g)
2008-01-10: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029D)
2008-01-09: Information on Verifying OnStar System Function During Pre-Delivery Inspection (PDI) (06-08-46-006A)
2008-01-09: Availability of GM OnStar Vehicle Diagnostics and GM Goodwrench Remote Diagnostic Services (06-08-46-002B)
2008-01-09: Seat Belt Extender Availability (99-09-40-005E)
2008-01-09: Information on Tire Radial Force Variation (RFV) (00-03-10-006C)
2008-01-09: OnStar Labor Operation Codes (05-08-46-005B)
2008-01-08: Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems (02-08-44-007C)
2008-01-08: OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System (05-08-46-004B)
2008-01-08: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call (02-08-46-006C)
2008-01-07: Intermittent SES Light Due To DTCs P060E P2135 And/Or P2138 - keywords chaff circuit connection controls ECM engine ground L61 LSJ no PCM short terminal wire wiring (PIP4175B)
2008-01-07: Tire Puncture Repair Procedures for All Cars and Light Duty Trucks (04-03-10-001D)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2008-01-02: Check Engine Light On, DTCs P0171, P0300, P1174 Set (Perform Injector Test/Replace Injectors and Reprogram ECM, if Necessary) (08-06-04-001)
2007-12-27: Intermittent Current Or History DTC B2476 In OnStar GEN 5 6 Or 7 VCIM - keywords B2476 blue button call communication data digital information keypad led onstar OPC operation red (PIC4574A)
2007-12-20: Passenger Seatbelt Light On With Nobody In Front Passenger Seat- keywords belt chime display empty flash flashing ind indicator inop inoperative int intermittent initialized lamp message no presence (PIC4553A)
2007-12-19: Continuous OnStar Progression Tones AFTER Call End Attempt Is Made - keywords blue button DTC emerging flashes inoperative issue led mute no noconnect OnStar progression radio red tones (PIC4500A)
2007-12-19: Airbag Readiness Light ON with DTC B0081 or B0092 Set in Passenger Presence System (PPS) SDM (Remove Passenger Seat Cushion Cover and Allow to Dry) (06-09-41-008C)
2007-12-17: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-062)
2007-12-17: Warranty Parts Center/Corporate Parts Return Program (99-00-89-019E)
2007-12-13: Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical (UBEC, BEC, Fuse Block, Electrical Center) Concerns (07-00-89-060)
2007-12-13: Essential Service Tool Update #8 (U.S. Retailers Only) (07-00-89-061)
2007-12-12: Spare Tire Hold Down Stud for Spare Tire Sticks Up Through Load Floor (Install Nut) (07-08-110-009)
2007-12-10: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) (03-06-04-030F)
2007-12-06: Chrome Wheel And Trim Corrosion - keywords body door molding tire warranty (PIT4548)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-12-04: Unwanted OnStar Turn By Turn Operation At Startup - keywords message navigation onstar OPC TBT turn unwanted (PIC4701)
2007-11-30: Difficult to Rotate or Cant Remove Key From Ignition - keywords 03 04 05 06 07 08 AB adjust bind cylinder hard ignition intermittent ION key saturn shifter stuck switch turn PIC4477 PIC4477A (PIC4477A)
2007-11-30: OnStar Unwanted or Phantom Phone Calls - keywords call handsfree intermittent mmute OnStar OPC performance phantomcalls unwanted (PIC3278C)
2007-11-29: GWM Warranty Parts Center Return Program (05-00-89-042C)
2007-11-26: Intermittent SES Light Due To DTCs P060E P2135 And/Or P2138 - keywords chaff circuit connection controls ECM engine ground L61 LSJ no PCM short terminal wire wiring (PIP4175A)
2007-11-21: Release of DEXRON-VI Automatic Transmission Fluid (ATF) (04-07-30-037D)
2007-11-19: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029C)
2007-11-19: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007C)
2007-11-13: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-056)
2007-11-13: GM Training: 2008 Service Training Standards (STS) Updates (U.S. Dealers) (07-00-89-055)
2007-11-12: Customer Concern Not Duplicated/Verified Labor Operations (06-00-89-026A)
2007-11-09: Underbody Corrosion - keywords appearance body frame rust (PIT3749B)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008D)
2007-11-02: Unable To Connect In Laurel, Pulaski and Rockastle Counties, KY.Other Areas may have this same concern. (PIC3549A)
2007-11-02: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication digital failedtovoice information intermittent OnStar OPC operation no noconnect (PIC4310A)
2007-11-01: Trailer, Recreational and Disabled Vehicle Towing Information (07-00-89-054)
2007-10-31: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital information noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393F)
2007-10-31: Seat Belt Latch Stop Button Available for Service (07-09-40-002)
2007-10-31: Airbag Readiness Light ON with DTC B0081 or B0092 Set in Passenger Presence System (PPS) SDM (Remove Passenger Seat Cushion Cover and Allow to Dry) (06-09-41-008B)
2007-10-26: EI06042 - 2.2L L61 Coolant Loss, Leak, No Overheat Condition (Diagnose and Repair Per SI) (06-06-02-013F)
2007-10-24: Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
2007-10-23: Information on Proper Tire Pressure (00-00-90-002I)
2007-10-15: GM Training:I-CAR Offers Various Resources to Help Dealers Achieve Training Goals (U.S. Dealers) (07-00-89-051)
2007-10-15: GM Training:October 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-052)
2007-10-05: Disabled Onstar System Identification (PIC3597D)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-10-01: Information on 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shift, Slip, No Drive/Reverse (07-07-30-025)
2007-10-01: Intermittent Red LED DTC B2470 And Possible Unable To Contact OnStar Center - keywords analog blue button connect digital DTC information LED no OPC operation performance UE1 (PIC3341D)
2007-09-28: EI06042 - 2.2L L61 Coolant Loss, Leak, No Overheat Condition (Engineering Information) (06-06-02-013E)
2007-09-28: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
2007-09-21: Essential Service Tool Update #6 (U.S. Retailers Only) (07-00-89-049)
2007-09-21: Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires (03-03-10-007C)
2007-09-20: DTC P0843 - keywords 4T45E DTC MIL MN5 P0843 pressure release SES slip TCC (PIP4228)
2007-09-17: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016A)
2007-09-14: GM Training: FINAL REMINDER - Hybrid Two-Mode Training Information (U.S. Dealers) (07-00-89-046)
2007-09-14: GM Training: September 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-045)
2007-09-12: 4T45 Transmission, MIL/SES On, DTC P1818, Power Door Locks,Cruise Control, Shift Interlock or Retractable Hardtop Inop, Engine Speed Revs Limited, Hybrids-Autostop, Regen or Boost Inop (Reprogram TCM) (07-07-30-005B)
2007-09-12: No Communication with VCIM After TIS2WEB Service Programming System (SPS) - keywords communication message no noconnect onstar operation vs3bgen4 vs3bgen5 vs3bgen5 vs3bgen6 vsb3gen7 SPS (PIC4609)
2007-09-11: EI06042 - 2.2L L61 Coolant Loss, Leak, No OVerheat Condition (Engineering Information) (06-06-02-013D)
2007-09-05: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
2007-08-31: EI05093 - Clunk Noise in Steering System at Slow Speeds While Turning and/or Driving Over Bumps (Bulletin Canceled - See Bulletin 04-03-08-006B) (05-02-32-005E)
2007-08-31: Squeak, Rattle, Pop or Clunk Noise from Front of Vehicle During Suspension Movement (Bulletin Canceled - See Bulletin 04-03-08-006B) (04-03-08-003C)
2007-08-29: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords B1000 blue button communication DTC information message no noconnect OnStar operation (PIC4600)
2007-08-27: Steering and Front Suspension Noise Concerns - Clunk, Rattle, Knocking, Pop, Shudder, Vibration (Diagnosis and Perform Necessary Repair) (04-03-08-006B)
2007-08-24: Turn By Turn Will Not Cancel Route - blue button call cellular communication data digital information navigation operation turn vs3bgen7 (PIC4596)
2007-08-24: Use Of Driver / Passenger Load Tool SA9409Z-A Instead Of J38715A For Saturn Retailers - keywords B0012 B0013 B0014 B0015 B0016 B0019 B0020 B0021 B0022 B0023 B0025 communication information lamp light (PIC4598)
2007-08-23: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors (07-00-89-043)
2007-08-21: Vibration That Is Felt Through The Steering Column While Making Right Hand Turns - keywords accel acceleration accelerate condition driver full ground growl int intermittent MN% moan mount noise (PIC4305A)
2007-08-20: Diagnostic Tips for Power Steering Inoperative/Steering Wheel Hard to Turn, Power Steering Message Displayed on DIC, DTCs C0176, C0475, C0476, C0550, U2105, U2107 Set (07-02-32-007)
2007-08-17: GM Training:GM Service Technical College (STC) Northeast Regional Training Center Relocation (U.S. Dealers) (07-00-89-042)
2007-08-17: GM Training: Enhancement to Componentized Placement Assessments (U.S. Dealers) (07-00-89-041)
2007-08-17: GM Training:Hybrid Two-Mode Training Information (U.S. Dealers) (07-00-89-040)
2007-08-17: GM Training:August 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-039)
2007-08-16: Service Tools Released for Five-Speed Manual Transaxle/Transmission (RPO MU3) (05-07-29-001C)
2007-08-16: Warranty Admin. - Courtesy Transportation and Roadside Assistance Programs (07-00-89-037)
2007-08-14: Engine does Not Crank - Starter Solenoid Does Not Click - Monitor Ignition Accessory Voltage - keywords DTC DTCs no start (PIP4208)
2007-08-14: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016)
2007-08-10: OnStar Hands Free Calling Security Lock - Lost Pin Procedure - keywords blue button cellular free hand handsfree identification information inoperative lock number onstar OPC PIN security telephone (PIC4589)
2007-08-09: EI05093 - Clunk Noise in Steering System at Slow Speeds While Turning and/or Driving Over Bumps (Replace Intermediate Shaft) (05-02-32-005D)
2007-08-08: Importance of Using J-39637 - Wiper Removal Tool When Removing or Replacing Wiper Arms (07-08-43-007)
2007-08-06: OnStar Reactivation For Daily Rental Vehicles Purchased At Auction - keywords button communication disabled information message no noconnect OnStar operation rental vs3bgen6 vs3bgen7 (PIC4583)
2007-08-02: Dealers Seeking Technical Support For XM Digital Radio Receivers - keywords accessory aftermarket antenna information inoperative ksp radio xm xmradio (PIC3228E)
2007-08-02: OnStar Gen 6 With A Current DTC U1500 - keywords blue button call cellular communication data digital DTC led information noconnect onstar operation program red tech2 UE1 U1500 vs3bgen6 (PIC3718C)
2007-08-02: Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
2007-08-02: Warranty Admin. - GM Dealer Empowerment Program and Goodwill Procedures (05-00-89-055B)
2007-08-01: Clunk, Thump or Rattle Noise from Front Suspension While Driving Over Rough Road Conditions or When Braking (Replace Front Lower Control Arm Rear Bushing) (04-03-08-006A)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-27: EI06042 - 2.2L L61 Coolant Loss, Leak, No Overheat Condition (Engineering Information) (06-06-02-013C)
2007-07-26: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022D)
2007-07-25: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-033)
2007-07-20: Airbag On LIght (AOL) Indicator Loose Or Pushed In-keywords activation apperance blank break broken button check cluster dash disabled display function gauge inoperative instrument IPC lamp panel (PIT3677C)
2007-07-20: XM - Factory Kit RadioCompatibility - keywords DRR kit radio U1C UM7 UMS XM radio (PIC4575)
2007-07-20: Intermittent Current Or History DTC B2476 In OnStar Gen 5 6 or 7 VCIM - keywords B2476 blue button call communication data digital information keypad led onstar OPC red (PIC4574)
2007-07-19: Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
2007-07-19: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) (06-08-50-009B)
2007-07-19: Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
2007-07-12: Engine Block Casting Void - RTV Bleed Holes May Be Perceived As Porosity - keywords case crank crankcase half leak oil (PIP4178)
2007-07-12: Cylinder Miss On Left Turns And Cylinder 4 Miss On Right Turns - Possible Fuel Contamination - keywords CEL contaminated controls cylinders gas injector intermittent MIL misfire P0300 P0301 rail rust (PIP3333A)
2007-07-10: Low Oil Pressure - Inspect Oil Filter For Damage - keywords adjuster after change engine hot idle indicator lamp lash lifter light LOF mechanical no noise rattle tick (PIP3859A)
2007-07-09: Intermittent DTCs P0325 P2135 And/Or P2138 - Inspect For Shorts To Ground - keywords CEL chaff controls engine no wire (PIP4175)
2007-07-03: Fuel Tank Is Slow To Fill And/Or DTC P0446 - keywords CEL debris engine hard hose MIL pipe restricted SES tube (PIP3627A)
2007-06-29: OnStar Handsfree Calling (OHFC) Inoperative And OnStar Blue Button Keypress Is Now Receiving The Demo Message - keywords 05-08-46-006M blue button communication digital disabled message no OnStar OPC (PIC4564)
2007-06-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for June, 2007 (06-00-89-041G)
2007-06-29: Intermittent no connect Gen 6 or Gen 7 (PIC4551)
2007-06-29: Language Change for OnStar System (U.S. and Canada Only) (05-08-46-009B)
2007-06-27: GM Training:Introducing 2007 Saturn Training Bonus (U.S. Dealers) (07-00-89-029)
2007-06-27: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 (07-01-38-004)
2007-06-27: GM Training:May 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-028)
2007-06-26: Accessory Package - Installation of Cargo Capacity Reduction Label (U.S. Only) (07-00-89-027)
2007-06-26: GM Training:April 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-025)
2007-06-26: GM Training:Service Training Standard (STS) Effective Date for Two Required Technology Close-ups (TCUs) was 04/14/07 (U.S. Dealers) (07-00-89-024)
2007-06-26: GM Training:Saturn Report Changes (U.S. Dealers) (07-00-89-017)
2007-06-26: GM Training:Announcing the 2008 Body Structural and Painting Service Training Standards (STS) Requirements for Saturn Dealers (U.S. Dealers) (07-08-51-002)
2007-06-26: GM Training:Number of Technicians Required Reduced for Two Categories (U.S. Dealers) (07-00-89-016)
2007-06-26: GM Training:Three Technology Close-Up IDL Seminars as New 2007 Service Training Standard (STS) Requirements (U.S. Dealers) (07-00-89-014)
2007-06-26: GM Training:March 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-013)
2007-06-26: GM Training:Course Information (For U.S. Dealers and Aftermarket) (07-00-89-011)
2007-06-26: GM Training:January 2007 GM Service Know-How Emerging Issues Seminar (#10207.01D) (For U.S. Dealers Only) (07-00-89-007)
2007-06-26: GM Training:Maintaining GM STC Master Technician Certification (MTC) (For U.S. Dealers Only) (07-00-89-005)
2007-06-26: GM Training:HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) (07-01-38-001)
2007-06-26: GM Training:Saturn Person Types Renamed on the GM Training Website (For U.S. Dealers Only) (07-00-89-006)
2007-06-25: Seat Cushion Cover Loose (Secure J-Strip to Seat Frame with Hog Rings) (06-08-50-005B)
2007-06-22: SES Light Due To DTCs P0449 P0455 And/Or P2431 - Reprogram ECM - keywords calibration CEL check DTC engine lamp line MIL no program repeat (PIP4078A)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-22: Use of Silicone for Weatherstrip Maintenance (99-08-64-016B)
2007-06-21: Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector) (07-06-04-019)
2007-06-21: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage (00-06-01-026B)
2007-06-19: No OnStar LED - keywords blue button communication digital disabled led information no nopower operation UE1 (PIC3597C)
2007-06-19: Passenger Seat Belt Light On With Nobody In Front Passenger Seat - keywords belt chime display empty flash flashing ind indicator inop inoperative int intermittent initialized lamp message no presence (PIC4553)
2007-06-18: Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
2007-06-15: Driveability/Tachometer Issues With Various DTCs - keywords contact cover crank ecm engine ground harness hesitate hot int intermittent inop inoperative light lamp misfire no p0030 p0036 p0102 p0445 (PIC4283A)
2007-06-14: Communication Strategy of Service Information/Strategy Based Diagnostics (05-00-89-067B)
2007-06-13: Safety Belt Locking Conditions (Normal Operating Characteristic) (05-09-40-002B)
2007-06-12: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT - CH-47976) (03-06-04-030E)
2007-06-12: 4T45 Transmission, MIL/SES On, DTC P1818, Power Door Locks, Cruise Control, Shift Interlock or Retractable Hardtop Inoperative, Engine Speed Revs Limited, Hybrids-Autostop, Regen or Boost Inoperative (07-07-30-005A)
2007-06-08: Windshield Wiper Performance, Cleaning Instructions and Maintenance (06-08-43-003A)
2007-06-06: Audio Whine Noise from Radio Speakers When Using OnStar (Install Noise Suppression Filter) (07-08-46-002)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-31: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital information noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393E)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-24: Corrosion Protection for Metal Panels with Dealer Installed Accessories Fastened by Drilled Holes (03-00-89-008C)
2007-05-23: Content Theft Deterrent System Cannot Be Disarmed by Cycling Key in Ignition After Unlocking Door with Key (reprogram PCM) (07-08-56-001)
2007-05-23: Disc Brake Warranty Service and Procedures - LRO, Lateral Runout, Rotor, Corrosion, Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Squeak, Grind, Groan (05-05-22-002C)
2007-05-16: OnStar TBT (Turn By Turn) And Digit Displays Location - keywords call cellular communication data digit digital hud information operation radio turn unable use (PIC4510)
2007-05-09: Interior Cleaning, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - New Product Availability (06-00-89-029B)
2007-05-08: Continuous OnStar Progression Tones AFTER Call End Attempt Is Made - keywords blue button DTC AIC3287 emerges flashing inoperative issue led mute no noconnect OnStar progression radio red tones (PIC4500)
2007-05-03: Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software (07-07-30-010)
2007-04-25: Key Difficult To Remove When Ignition Is Off And Shift Select Lever Is In Park - keywords bind column cylinder inoperative intermittent lock key shift shifter stuck (PIC3596A)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-19: Service Engine Soon (SES) Light Illuminated, DTC P0442 Set (Reprogram PCM) (07-06-04-012)
2007-04-18: OnStar Customer Reports (Phantom Phone Calls) Without Attemping A Call - keywords calling calls cellular free hands HFC intermittent mute OPC performance phantomcalls UE1 (PIC3278B)
2007-04-17: Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition) (07-03-10-008)
2007-04-17: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-16: MG3, M86 Manual Transaxle Grinding or Growling Noise in 3rd or 4th Gear, Excessive Engagement or Disengagement Effort While Shifting into 5th or Reverse Gear, Will Not Shift into Either 5th or Reverse (07-07-29-001A)
2007-04-12: Difficult to Rotate Key Or Cannot remove Key From Ignition Cylinder - keywords 03 04 05 06 07 8 AB adjust bind cylinder hard ignition intermittent ION key saturn shifter stuck switch turn (PIC4477)
2007-04-03: Poor Audio Quality When Listening to AM or FM Radio (Reprogram Radio) (06-08-44-016C)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-04-02: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair (07-08-98-001)
2007-03-30: Floor Pan Corrosion (Rust) Perforation in Battery Compartment (Install Repair Panel) (07-08-61-005)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-23: Warranty Admin. - Front Seat Cushion Frame Replacement and Front Seat Back Frame Replacement Labor Operations C6060 and C6068 (07-08-50-006)
2007-03-16: Information on Paint Stain Under Protective Shipping Film (05-08-51-001B)
2007-03-13: Information on OnStar System - Possible Loss of GPS and/or Unable to Replenish Hands-Free Calling Minutes (02-08-46-007B)
2007-02-26: Leather Shift Boot/Knob Substituted For Plastic - keywords 07 AB accessory knob leather manual shifter (PIC4427)
2007-02-23: Information on Use of Correct Engine Coolant Heater Cord to Avoid Setting DTC P0116 (07-06-02-002)
2007-02-15: Info - New Bulletin Category: Technical Training (U.S. Only) (07-00-89-003)
2007-02-13: XM Radio Inoperative After Radio Replacement - keywords information lock saturn techII theft theflock U2K (PIC3389C)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-31: Momentary Sag On Light Due To Moderate Accel When Cold - Valve Deposits - keywords acceleration additive black brief carbon cleaner decarbon DTC engine exhaust fuel gasoline hesitation intake no smoke (PIP3644C)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-23: Noise from Rear Of Vehicle - keywords canister cold CVS click evap knock L61 LE5 noise rear solenoid tick vent (PIC4317B)
2007-01-23: Info - Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
2007-01-19: Front Door Glass Does Not Move Up or Down and/or Inoperative or Jerky/Uneven Motion (Inspect Window Regulator and Tighten Cam Bolt Torque) (06-08-64-020A)
2007-01-18: SES Light Due To A P1174 DTC - Perform Injector Test With AFIT - CH47976 - keywords active balance cylinder engine fuel injector lamp light misfire miss P0300 test tester (PIP4017A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-17: Info - Diagnostic Trouble Codes (DTCs) Required on Repair Orders (06-00-89-050A)
2007-01-15: Inaccurate Tachometer At High RPM with GM Performance Parts Stage 1 Or 2 Kit - keywords accuracy cut cutoff early engine fuel high I II kit limit limiter no off rev RPM stage superch17801947 17803229 (PIP4023)
2007-01-15: SES Light With DTCs P0101 P0103 P0172 And/Or P0420 - Inspect ir Filter For Water - keywords black catalytic cleaner cold controls converter engine intrusion MIL repeat replacement rough running smoke (PIP3710C)
2007-01-11: Digital Radio Receiver Rapid Activation Utilization - keywords diagnosis digital DRR exchange information lock module no number part radio receiver reception reman satellite U2K (PIC4374)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-11: Airbag Readiness Light ON with DTC B0081 or B0092 Set in Passenger Presence System (PPS) SDM (Remove Passenger Seat Cushion Cover and Allow to Dry) (06-09-41-008A)
2007-01-11: Squeak, Rattle, Pop or Clunk Noise from Front of Vehicle During Suspension Movement (Replace Front Stabilizer Shaft Insulators) (04-03-08-003B)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Parts Update - Timing Chain Tensioner Design Change - keywords adjuster after change chain chevrolet damage design engine filter hot idle indicator information lamp lash lifter light mechanical no (PIP4014)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2006-12-28: Intermittent Red LED DTC B2470 And Possible Unable To Contact OnStar Center - keywords analog blue button connect digital DTC information led no opc operation performance PIC3341 PIC3341A PIC3341B UE1 (PIC3341C)
2006-12-21: Information on Adjusting Key Cut Depths in Exacta Key Cutting Machine (06-00-89-053A)
2006-12-15: Waterleak at Front Door Window Frame (Fill In/Refinish Step Area on Door Frame) (05-08-57-003B)
2006-12-14: Ignition Key Is Difficult To Turn To The Run Position - keywords 07 8 ab bind ignition ION hard housing key nocrank nostart Saturn stuck switch turn (PIC4297A)
2006-12-14: Information on HemFlange Sealer for Corrosion Protection (06-08-51-005)
2006-12-14: Info - Essential Service Tool Update #9 (U.S. Retailers Only) (06-00-89-056)
2006-12-12: Water Intrusion/Leak Into Passenger Compartment When Opening Sunroof (Install Drains) (06-08-67-020)
2006-12-07: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001E)
2006-12-05: Headliner Wet at Center Map Light/Sunroof Switch Area (Adjust Sunroof and Apply Lube) (06-08-67-019)
2006-11-30: Warranty Admin. - Brake Rotor/Drum Refinishing Labor Operations (06-05-22-007)
2006-11-29: OnStar Vehicles - Voice Recognition Inoperative - keywords analog celleular communication digital intermittent UE1 vs3bcu vs3bgen2 vs3bgen3 vs3bgen4 vs3bgen5 vs3bgen6 vs3bgen7 (PIC3011D)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-17: Info - Essential Service Tool Update Number 8 (U.S. Retailers Only) (06-00-89-049)
2006-11-10: Machining Debri On The Oil Filter Element - Replace Oil And Filter - keywords aluminum change chips contamination engine metal shaving (PIP3404C)
2006-11-09: Crank No Start When Cold Due To Compression Loss - keywords cylinder cylinderhead extended hard head lifter loss (PIP3146B)
2006-11-09: Radio And Instrument Panel Cluster Parts Restrictions - keywords CD cluster instrument information panel part radio (PIT4068A)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Information on Inadvertent Turning of Key Cylinder, Loss of Electrical System and No DTCs (05-02-35-007A)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-20: SES Light Illuminated, DTCs P0171, P0300, P1133 Set, Reduced Performance, Hard Start, No Start, Intermittent Lack of Power (Replace Fuel Pump) (06-06-04-047A)
2006-10-19: Navigation Radio Displays No GPS Signal - keywords onstar UE1 (PIT4118B)
2006-10-12: Instrument Panel Cluster (IPC) Lens Cloudy, Scratched, Cracked, or Broken (Replace IPC Lens Only) (06-08-49-002A)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-04: Info - Updated Pre-Delivery Inspection (PDI) and Completely Satisfied Delivery System (CSDS) Forms Now Available (04-00-89-052A)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-29: Transmission fluid Leak Slipping Clutch Or Broken Axle Shaft - keywords crack housing shift slip (PIP3932)
2006-09-28: Service VME - Additional Information About Passenger Presence Systems (PPS) - keywords bladder information passenger PPS presence restraint seat sensor SIR system weight (PIT4138)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-27: Info - Availability of Steering Knuckles for Competitive Driving (06-03-08-001D)
2006-09-27: Wheel Alignment Service Specifications - keywords pull steering suspension tire turn wear left right (PIT4135)
2006-09-25: Rear Defogger Grid Inoperative or Incomplete Defogging of Rear Glass (Repair Broken Defogger Grid Wires) (05-08-48-003B)
2006-09-22: Info - New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores (03-00-89-006D)
2006-09-19: Reduced Audio Volume Level When First Tuned to AM Radio or Loss of Volume After Signal Strength Reduction (Reprogram Radio) (06-08-44-030)
2006-09-15: Information Regarding Updated PC Grade Specifications and Techline Support (U.S. Only) (06-00-89-045)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-08: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (06-08-111-004)
2006-09-08: Inaccurate Fuel Gauge Readings, Fuel Gauge Reads Empty When There is Fuel in Tank, Low Fuel Message Displayed in DIC, DTC P0461 Set (Reprogram ECM) (06-08-49-018)
2006-09-07: Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010)
2006-09-06: Window Switch Not Illuminated - keywords door inoperative light switch window (PIC4191)
2006-08-30: Power Steering Inoperative/Steering Wheel Hard to Turn, PWR STR Message Displayed on Driver Information Center (DIC) After Jump Starting Vehicle (Replace Fuse/Instruct Owner How to Jump Start Vehicle) (05-02-32-002C)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-17: 4T65E Whine Noise Park/Neutral - keywords bearing drive sprocket support (PIP3894)
2006-08-17: 4T65E DTC P0742 and P2764 - keywords PWM solenoid TCC (PIP3895)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-15: Intermittent No Crank/No Start, Clicking Noise When Key Turned to Start, Security Light May Flash, Service Vehicle Messge in DIC, DTC B2960 and/or B3033 Set (Replace Ignition Switch) (06-02-35-017)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: SES Light Due To A P0442 and/or P0455 DTC - Inspect Evap Pipe At Fuel Tank - keywords lamp leak line (PIP3746A)
2006-08-04: Exchange Program - Saturn Aura, ION, Relay, SKY and VUE Instrument Panel Cluster Ordering Process (05-08-49-009D)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-04: Info - Saturn Aura, ION, Relay, Sky and VUE Radio Receiver Ordering Process (05-08-44-007C)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-06-21: Info - Installation of Remote Keyless Entry (RKE) to ION-2 Vehicles (03-08-52-006B)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-16: Transmission Case or Channel Plate Replacement - keywords bolt cover thread (PIP3842)
2006-06-12: Info - Engine and Automatic Transmission/Transaxle Identification (06-00-89-031)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-05: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for May, 2006 (06-00-89-028)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
2006-04-20: Engine Dieseling/Run On When Engine is Turned Off Cold - keywords characteristic crank delayed diesel DTC key normal runon stop warm (PIP3789)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-04-03: Door Latch Freezing in Cold Temperatures (Apply Super Lube) (05-08-64-002B)
2006-03-31: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for March, 2006 (06-00-89-017)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-07: Intermittent No Crank, No Start (Clean Battery Side Terminal Stripped Threads, Replace Battery Cable Bolt) (02-06-04-015A)
2006-03-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for February, 2006 (06-00-89-012)
2006-02-24: Service VME - Underbody Corrosion - keywords appearance body frame rust (PIT3749A)
2006-02-24: Questions Regarding Installation of Dealer Installed Accessories - keywords 2.8 3.5 4.2 4.8 5.3 6.0 8.1 accessory part Partech (PIT3099C)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-27: Info - Essetnial Service Tool Update No. 1 (U.S. Retailers Only) (06-00-89-005)
2005-12-21: Info - Essential Service Tool Update No. 7 (U.S. Retailers Only) (05-00-89-087)