Low, No Windshield Washer Flow (Replace Washer Pump Filter with Plain Grommet)
| Subject: | Low, No Windshield Washer Flow (Replace Washer Pump Filter with Plain Grommet) |
| Models: | 2007-2008 Chevrolet Equinox |
| 2007-2008 Pontiac Torrent |
| Built Prior to October 1, 2007 |
This bulletin is being revised to emphasize not to replace the washer pump motor and to check the washer fuse. Please discard Corporate Bulletin Number 08-08-43-005 (Section 08 -- Body and Accessories).
Condition
Some customers may comment on low or no windshield washer flow.
Cause
This condition may be caused by a clogged washer pump filter. Extended use with the filter clogged may have also caused the washer pump to burn out.
Correction
Technicians are to replace the pump filter with a new style plain grommet.
Do This | Don't Do This |
|---|---|
Replace only the washer pump filter, and if necessary the washer fuse. | Don't replace the washer pump motor. |
Important: If further diagnosis leads to the washer pump motor being inoperative, replace the windshield washer pump motor.
- Remove the windshield washer container. Refer to SI for Windshield Washer Solvent Container Replacement.
- Remove the washer solvent filter grommet from the pump.
- Replace the washer solvent pump filter grommet with a new part (see figure above).
- Verify the washer fuse is not blown- refer to SI for the location of the fuse.
Important: DO NOT replace the washer pump motor and kit unless further diagnosis leads you to an inoperative pump.
Parts Information
Part Number | Description | Qty |
|---|---|---|
90045821 | Gasket (Grommet) | 1 |
Warranty Information
For vehicles repaired under warranty, use:
Labor Operation | Description | Labor Time |
|---|---|---|
N9520* | W/S Washer Pump Grommet Repair | 0.6 hr |
*This labor operation number is for bulletin use only. This number will not be published in the Labor Time Guide. | ||
