GM Service Manual Online
For 1990-2009 cars only
Makes 🢒 Chevrolet 🢒 2000 🢒 Tracker - 2WD 🢒 General Information 🢒 Maintenance and Lubrication 🢒 Maintenance Schedule - Short Trip/City

The services shown in this schedule up to 166 000 km (100,000 mi) should be performed after 166 000 km (100,000 mi) at the same intervals.

Footnotes

[Dagger] The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

+ A good time to check brakes is during tire rotation. Inspect the complete system. Inspect brake lines and hoses for proper hook-up, binding, leaks, cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also inspect drum brake linings for wear and cracks. Inspect other brake parts, including drums, wheel cylinders, calipers parking brake, etc. Check parking brake adjustment. You may need to have your brakes inspected more often if your driving habits or conditions result in frequent braking.

# Lubricate the parking brake lever and cable, suspension system and propeller shafts, and steering wheel linkage.

5 000 km (3,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

10 000 km (6,000 Mi)

    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

15 000 km (9,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

20 000 km (12,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

25 000 km (15,000 Mi)

    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect engine air cleaner filter if vehicle is driven under dusty conditions. Replace filter if necessary. An Emission Control Service. See footnote [Dagger].
    • For two-wheel drive vehicles only: Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain
       - When doing frequent trailer towing
       - Uses such as found in taxi, police or delivery service
       - If vehicle is not used under these conditions, change the fluid and filter every 166 000 km (100,000 mi).
    • Change the manual transmission fluid.
    • Change the transfer case fluid.
    • Change the differential fluid.
    • Inspect the valve lash (1.6 L only) and adjust if necessary. An Emission Control Service.
    • Inspect propeller shafts and U-joints for looseness and damage (or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

30 000 km (18,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

35 000 km (21,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

40 000 km (24,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

45 000 km (27,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

50 000 km (30,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Replace the AC evaporator air filter.
    • Inspect the fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed.
    • Inspect engine accessory drive belts (or every 24 months, whichever occurs first). An Emission Control Service.
    • Drain, flush and refill cooling system (or every 30 months, whichever occurs first). Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. See footnote [Dagger].
    • For two-wheel drive vehicles only: Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Replace spark plugs (1.6 L only). An Emission Control Service.
    • Replace engine air cleaner filter. An Emission Control Service.
    • Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain
       - When doing frequent trailer towing
       - Uses such as found in taxi, police or delivery service
       - If vehicle is not used under these conditions, change the fluid and filter every 166 000 km (100,000 mi).
    • Rotate Tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.
    • Change manual transmission fluid
    • Change transfer case fluid.
    • Change differential fluid.
    • Inspect valve lash (1.6 L only) and adjust if necessary. An Emission Control Service.
    • Replace fuel filter (or every 30 months, whichever occurs first, or sooner if filter is clogged). An Emission Control Service. See footnote [Dagger].
    • Inspect propeller shafts and U-joints for looseness and damage (or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

55 000 km (33,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

60 000 km (36,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

65 000 km (39,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

70 000 km (42,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

75 000 km (45,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • For two-wheel drive vehicles only: Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Replace automatic transmission fluid hose (or every 45 months, whichever occurs first).
    • Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain
       - When doing frequent trailer towing
       - Uses such as found in taxi, police or delivery service
       - If vehicle is not used under these conditions, change the fluid and filter every 166 000 km (100,000 mi).
    • Inspect engine air cleaner filter if vehicle is driven under dusty conditions. Replace filter if necessary. An Emission Control Service. See footnote [Dagger].
    • Change manual transmission fluid.
    • Change transfer case fluid.
    • Change differential fluid.
    • Inspect the valve lash (1.6 L only) and adjust if necessary. An Emission Control Service.
    • Inspect propeller shafts and U-joints for looseness and damage (or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

80 000 km (48,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

83 000 km (50,000 Mi)

Replace Positive Crankcase Ventilation (PCV) valve. Replace any worn, plugged or collapsed hoses. An Emission Control Service.

85 000 km (51,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

90 000 km (54,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

95 000 km (57,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

100 000 km (60,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Replace AC evaporator air filter.
    • For two-wheel drive vehicles only: Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain
       - When doing frequent trailer towing
       - Uses such as found in taxi, police or delivery service
       - If vehicle is not used under these conditions, change the fluid and filter every 166 000 km (100,000 mi).
    • Inspect engine accessory drive belts (or every 24 months, whichever occurs first). An Emission Control Service.
    • Drain, flush and refill cooling system (or every 30 months, whichever occurs first). Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. See footnote [Dagger].
    • Replace spark plugs. An Emission Control Service.
    • Replace spark plug wires (or every 60 months, whichever occurs first). An Emission Control Service.
    • Inspect the underhood wiring harness for loose connections, chafed wires and damage (or every 60 months, whichever occurs first). An Emission Control Service. See footnote [Dagger].
    • Drain, refill and bleed the brake system.
    • Replace the camshaft timing belt (1.6 L only). An Emission Control Service. See footnote [Dagger].
    • Inspect the fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed.
    • Replace engine air cleaner filter. An Emission Control Service.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.
    • Replace fuel filter (or every 30 months, whichever occurs first). An Emission Control Service. See footnote [Dagger].
    • Change manual transmission fluid.
    • Change transfer case fluid.
    • Change differential fluid.
    • Inspect the valve lash (1.6 L only) and adjust if necessary. An Emission Control Service.
    • Inspect emission system hoses and replace as necessary. An Emission Control Service. See footnote [Dagger].
    • Inspect propeller shafts and U-joints for looseness and damage (or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

105 000 km (63,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

110 000 km (66,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

115 000 km (69,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

120 000 km (72,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

125 000 km (75,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • For two-wheel drive vehicles only: Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain
       - When doing frequent trailer towing
       - Uses such as found in taxi, police or delivery service
       - If vehicle is not used under these conditions, change the fluid and filter every 166 000 km (100,000 mi).
    • Inspect engine air cleaner filter (in dusty conditions). Replace filter if necessary. An Emission Control Service. See footnote [Dagger].
    • Change manual transmission fluid.
    • Change transfer case fluid.
    • Change differential fluid.
    • Inspect the valve lash (1.6 L only) and adjust if necessary. An Emission Control Service.
    • Inspect propeller shafts and U-joints for looseness and damage (or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

130 000 km (78,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

135 000 km (81,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

140 000 km (84,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

145 000 km (87,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

150 000 km (90,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Replace AC evaporator air filter.
    • For two-wheel drive vehicles only: Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Replace automatic transmission fluid hose (or every 45 months, whichever occurs first).
    • Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain
       - When doing frequent trailer towing
       - Uses such as found in taxi, police or delivery service
       - If vehicle is not used under these conditions, change the fluid and filter every 166 000 km (100,000 mi).
    • Inspect engine accessory drive belts (or every 24 months, whichever occurs first).
    • Inspect camshaft timing belt (1.6 L only). An Emission Control Service. See footnote [Dagger].
    • Inspect the fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed.
    • Drain, flush and refill cooling system (or every 30 months, whichever occurs first). Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. See footnote [Dagger].
    • Replace spark plugs (1.6 Liter Only). An Emission Control Service.
    • Replace engine air cleaner filter. An Emission Control Service.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.
    • Change the manual transmission fluid.
    • Change transfer case fluid.
    • Change differential fluid.
    • Inspect the valve lash (1.6 L only) and adjust if necessary. An Emission Control Service.
    • Replace fuel filter (or every 30 months, whichever occurs first). An Emission Control Service. See footnote [Dagger].
    • Inspect propeller shafts and U-joints for looseness and damage (or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

155 000 km (93,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

160 000 km (96,000 Mi)
    • Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
    • Inspect AC evaporator air filter.
    • Rotate tires. Refer to Explanation of Scheduled Services for proper rotation pattern and additional information. See footnote +.

165 000 km (99,000 Mi)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

166 000 km (100,000 Mi)
    • Change automatic transmission fluid and filter (severe conditions).
    • Replace Positive Crankcase Ventilation (PCV) valve. Replace any worn, plugged or collapsed hoses. An Emission Control Service.
    • Inspect Exhaust Gas Recirculation (EGR) system. An Emission Control Service.
    • Replace evaporative emissions canister. An Emission Control Service.